Section 214.603 Emission Limitations
IllinoisRegulations
Ask Donna
How this section applies to your facts.
Illinois Administrative Code › Title 35 › › Part › Section 214.603 Emission Limitations
Text
TITLE 35: ENVIRONMENTAL PROTECTION
SUBTITLE B: AIR POLLUTION
CHAPTER I: POLLUTION CONTROL BOARD
SUBCHAPTER c: EMISSION STANDARDS AND LIMITATIONS FOR STATIONARY SOURCES
PART 214 SULFUR LIMITATIONS
SECTION 214.603 EMISSION LIMITATIONS
Section
214.603 Emission Limitations
The owner
or operator of a source must comply with the following emission limitations, as
applicable, expressed in terms of pounds of SO
2
emitted per clock
hour.
a) Aventine Renewable
Energy lb/hr
1) Cyclone East controlling
First 0.27
Germ
Drying System
2) Cyclone West controlling
First 0.37
Germ
Drying System
3) Second Germ Drying
System 0.01
4) Gluten Dryer 4 3.12
5) Gluten Dryer 9 10.50
6) Germ Dryer 1 4.98
7) Germ Dryer 3 4.26
8) Yeast Dryer 1.50
9) Scrubber controlling
Steep 1.79
Acid
Tower
10) Biogas Flare 0.001
11) Boiler A 0.00
12) Boiler B 0.00
13) Boiler C 0.00
b) Illinois
Power Resources Generating
E.D
1.79
Acid
Tower
10) Biogas Flare 0.001
11) Boiler A 0.00
12) Boiler B 0.00
13) Boiler C 0.00
b) Illinois
Power Resources Generating
E.D. Edwards lb/hr
1) Units 1 and 2 combined 2100.00
2) Unit
3 2756.00
3) Unit
3, if both Units 1 and 2 4000.00
permanently
shut down
c) Ingredion Bedford Park lb/hr
1) Feed Transport System 24.38
2) Wet Milling: Inside
In-Process 107.26
Tanks
3) Wet Milling: Molten
Sulfur Burner 7.01
and
Absorption System
4) Wet Milling: Outside
In-Process 2.69
Tanks
5) Germ Processing Facility
Channel 1 13.36
System
6) Germ Processing Facility
Channel 2 7.07
System
7) Germ Processing Facility
Channel 3 7.07
System
8) Germ Processing Facility
Channel 4 7.07
System
d) Midwest Generation
Joliet lb/hr
1) Joliet 9: Unit 6 189.82
2) Joliet 29: Unit 7 323.29
3) Joliet 29: Unit 8 342.15
e) Midwest Generation
Powerton lb/hr
1) Boilers 51, 52 (Unit 5)
and 61, 62 3452.00
(Unit 6) combined
2) The owner or operator
must comply with the emission limitation set forth in subsection (e)(1) on a
30-operatin
323.29
3) Joliet 29: Unit 8 342.15
e) Midwest Generation
Powerton lb/hr
1) Boilers 51, 52 (Unit 5)
and 61, 62 3452.00
(Unit 6) combined
2) The owner or operator
must comply with the emission limitation set forth in subsection (e)(1) on a
30-operating day rolling average basis. For purposes of this Subpart, an
operating day is a
calendar day in which any emission
unit addressed in subsection
(e)(1)
combusts
any fuel;
3) Within 24 hours after
the end of each averaging period, the owner or operator must use the following
equation to determine the combined SO
2
emission rate of the emission
units addressed in subsection (e)(1) for each averaging period, which concludes
at the end of each operating day. The SO
2
emission rate must not
exceed the limitation set forth in subsection (e)(1):
Where:
E
avg
= SO
2
emission rate for the averaging period, in lb/hr.
E
h
= SO
2
emission rate for stack operating hour "h" in the averaging period.
For purposes of this Subpart, a stack operating hour is a clock hour in which
valid data is obtained, and in which gases flow through the monitored stack or
duct for the emission units addressed in subsection (e)(1) (either for part of
the hour or for the entire hour) while at least one of the units is combusting
fuel.
n = Number of
stack operating hours in the averaging period in which valid data is obtained.
4) The SO
2
emission rate for the emission units addressed in subsection (e)(1) must not
exceed 6,000 lb/hr in more than 5% of the stack operating hours ("n"
in the equation in subsection (e)(3)) in any averaging period
the entire hour) while at least one of the units is combusting
fuel.
n = Number of
stack operating hours in the averaging period in which valid data is obtained.
4) The SO
2
emission rate for the emission units addressed in subsection (e)(1) must not
exceed 6,000 lb/hr in more than 5% of the stack operating hours ("n"
in the equation in subsection (e)(3)) in any averaging period.
f) Midwest
Generation Will County lb/hr
1) Unit 3 145.14
2) Unit 4 5000.00
g) Owens Corning lb/hr
1) Preheater Incinerator
System 1, including 44.69
emissions
from: Storage Tanks 9, 9A, 10,
10A,
11, 17, 18, 19, 20, 40, 41, 42, and 43;
Loading
Racks 1, 2, and 9; and Convertors
10
and 11
2) Preheater
Incinerator System 3, including 27.23
emissions
from: Converters 8, 9, 12,
13,
14, and 15; and Loading Racks 1, 2,
and
9
3) Regenerative Thermal
Oxidizer 3 4.33
controlling:
Storage Tanks 27, 28, 31,
32,
33, 34, 35, and 36
4) Regenerative Thermal
Oxidizer 4 6.38
controlling:
Storage Tank 98; Loading
Rack
PV1
5) Coating Operations
combined 0.15
h) Oxbow Midwest Calcining lb/hr
All
Calcining Units combined 187.00
This is a copy of a public record, reproduced as it was published. It is not legal advice, and it may not be the version a court would rely on. Check the official source before you cite it.