Jeremy Flax v. Daimler-Chrysler Corporation

IN THE SUPREME COURT OF TENNESSEE

AT NASHVILLE

October 25, 2007 Session Heard at Maryville1

JEREMY FLAX ET AL. v. DAIMLERCHRYSLER CORPORATION ET AL.

Appeal by Permission from the Court of Appeals, Middle Section

Circuit Court for Davidson County

No. 02C-1288 Hamilton V. Gayden, Jr., Judge

No. M2005-01768-SC-R11-CV - Filed July 24, 2008

The plaintiffs filed this products liability case against DaimlerChrysler seeking damages for the

wrongful death of their son and for emotional distress suffered by the mother. The plaintiffs also

sought punitive damages. We granted review to determine: 1) whether a negligent infliction of

emotional distress claim brought simultaneously with a wrongful death claim is a “stand-alone”

claim that requires expert medical or scientific proof of a severe emotional injury; 2) whether the

evidence presented at trial was sufficient to support an award of punitive damages; 3) whether the

punitive damages awarded by the trial court were excessive; and 4) whether the trial court erred by

recognizing the plaintiffs’ second failure to warn claim. We hold that the simultaneous filing of a

wrongful death suit does not prevent a negligent infliction of emotional distress claim from being

a “stand-alone” claim. Therefore, negligent infliction of emotional distress claims brought under

these circumstances must be supported by expert medical or scientific proof of a severe emotional

injury. In addition, we conclude that the punitive damages awarded by the trial court were

adequately supported by the evidence and were not excessive. Finally, we hold that the trial court

erred by recognizing the plaintiffs’ second failure to warn claim but conclude that the error did not

prejudice the judicial process or more probably than not affect the jury’s verdict. Accordingly, we

affirm the Court of Appeals’ reversal of the compensatory and punitive damage awards based on the

negligent infliction of emotional distress claim and reverse the Court of Appeals’ decision to

overturn the punitive damage award related to the plaintiffs’ wrongful death claim.

Tenn. R. App. P. 11 Appeal by Permission; Judgment of the Court of Appeals

Affirmed in Part and Reversed in Part

JANICE M. HOLDER, J., delivered the opinion of the court, in which WILLIAM M. BARKER , C.J.,

joined. CORNELIA A. CLARK, J., concurring in part and dissenting in part. GARY R. WADE, J.,

concurring. WILLIAM C. KOCH , JR., J., concurring in part and dissenting in part.

1

Oral argument was heard in this case in Maryville, Blount County, Tennessee, as part of this Court’s

S.C.A.L.E.S. (Supreme Court Advancing Legal Education for Students) project.

Alan J. Hamilton, George W. Fryhofer, III, James E. Butler, Jr., and Leigh Martin May, Atlanta,

Georgia, and Gail Vaughn Ashworth, Nashville, Tennessee, for the Appellants, Jeremy Flax and

Rachel Sparkman.

Dominic Lanza and Theordore J. Boutrous, Jr., Los Angeles, California; James C. Ho, Dallas, Texas;

Thomas H. Dupree, Jr., Washington, D.C.; and Joy Day and Lawrence A. Sutter, Franklin,

Tennessee, for the Appellee, DaimlerChrysler Corporation.

Louis A. Stockell, Jr., Madison, Tennessee, Pro Se.

Allison Orr Larsen, K. Lee Blalack, II, and Matthew M. Shors, Washington, D.C., for the Amicus

Curiae, Alliance of Automobile Manufacturers.

Christopher Landau and Robin S. Conrad, Washington, D.C., and John Randolph Bibb, Jr.,

Nashville, Tennessee, for the Amicus Curiae, The Chamber of Commerce of the United States of

America.

Jonathan M. Hoffman, Portland, Oregon, and Linda J. Hamilton Mowles, Knoxville, Tennessee, for

the Amicus Curiae, The Product Liability Advisory Council, Inc.

OPINION

I. Facts and Procedural History

On June 30, 2001, Rachel Sparkman and her eight-month-old son, Joshua Flax, were

passengers in a 1998 Dodge Grand Caravan (“the Caravan”) operated by Ms. Sparkman’s father, Jim

Sparkman. Ms. Sparkman was seated in a captain’s chair directly behind the driver’s seat. Joshua

Flax was restrained in a child safety seat in the captain’s chair directly behind the front passenger’s

seat, which Joe McNeil occupied.

As Mr. Sparkman turned left from a private drive onto a public road, the Caravan was rear-

ended by a pickup truck driven by Louis Stockell. According to the testimony of the accident

reconstruction experts, the pickup truck was traveling between fifty and fifty-six miles per hour at

the time of impact. The Caravan was traveling in the same direction at a speed between ten and

fifteen miles per hour. At the moment of the impact, the Caravan experienced a change in velocity

of approximately seventeen to twenty-three miles per hour. Accident reconstruction experts for both

parties testified that Mr. Sparkman was not responsible for the accident and that the accident would

not have occurred if Mr. Stockell had not been driving at an excessive speed.2

2

The plaintiffs’ expert testified that Mr. Stockell originally was traveling at approximately sixty miles per hour,

and the defendant’s expert testified that Mr. Stockell was traveling at approximately seventy miles per hour. The posted

speed limit on the public road at the time of the accident was thirty-five miles per hour.

-2-

Upon impact, the backs of the seats containing Mr. Sparkman, Ms. Sparkman, and Mr.

McNeil yielded rearward into a reclining position. Tragically, the front passenger’s seatback

collapsed far enough to allow the back of Mr. McNeil’s head to collide with Joshua Flax’s forehead.

The collision fractured Joshua Flax’s skull and caused severe brain damage. None of the other

passengers in the Caravan suffered serious injuries. Experts for both parties acknowledged that

Joshua Flax would not have been seriously injured if the seat in front of him had not yielded

rearward.

Immediately after the Caravan came to a rest, Ms. Sparkman checked on her son’s condition

and saw that his forehead had been, in her words, “smashed in.” Michael Loftis, one of the first

people to arrive at the scene of the accident, testified that he saw Ms. Sparkman outside the vehicle

holding Joshua Flax. Because he believed Ms. Sparkman was “kind of hysterical” and could have

accidentally caused further injury to Joshua Flax, Mr. Loftis offered to hold the child. Although

initially reluctant, Ms. Sparkman agreed to give her son to Mr. Loftis. At this point, Mr. Loftis first

observed that Joshua Flax had “a hole in his forehead approximately the size of a golf ball and

probably a half inch deep.” A short time later, Joshua Flax was transported to the hospital by

ambulance. He died of his injuries the next day.

On May 7, 2002, Ms. Sparkman and Joshua Flax’s father, Jeremy Flax, filed a complaint

against Mr. Stockell3 and DaimlerChrysler Corporation (“DCC”), the manufacturer of the Caravan.

The complaint alleged that the Caravan’s seats are defective and unreasonably dangerous, that DCC

failed to warn consumers that the seats pose a danger to children seated behind them, and that DCC

is strictly liable under the Tennessee Products Liability Act of 1978. Tenn. Code Ann. §§ 29-28-101

to -108 (2000). The plaintiffs further alleged that the condition of the seats and the failure to warn

proximately caused Joshua Flax’s death and caused Ms. Sparkman to suffer severe emotional

distress. Finally, the plaintiffs alleged that punitive damages are warranted because DCC acted

intentionally and recklessly in manufacturing, marketing, and selling the Caravan.

After a lengthy trial, the jury found that the seats were defective and unreasonably dangerous,

that DCC failed to warn the plaintiffs about the dangers of the seats at the time of sale, that DCC

failed to warn plaintiffs about the dangers of the seats after the sale, and that DCC acted recklessly

such that punitive damages should be imposed. The jury apportioned half of the fault to DCC and

the other half to Mr. Stockell. Finally, the jury awarded $5,000,000 to the plaintiffs for the wrongful

death of Joshua and $2,500,000 to Ms. Sparkman individually for negligent infliction of emotional

distress (“NIED”).

After the second stage of the trial, the jury awarded $65,500,000 in punitive damages to the

plaintiffs for the wrongful death of Joshua Flax and $32,500,000 in punitive damages to Ms.

3

Mr. Stockell failed to attend his scheduled deposition and failed to respond to DaimlerChrysler’s

interrogatories and request for production of documents. As a sanction, M r. Stockell was prohibited from testifying at

trial and from raising a defense against the plaintiffs’ claims. In addition, the trial court instructed the jury that Mr.

Stockell was at fault. Mr. Stockell is not a party to this appeal, and neither party has appealed any findings of fact or

conclusions of law with respect to Mr. Stockell.

-3-

Sparkman individually for NIED. Following the jury’s verdict, the trial court conducted a review

of the jury’s award of punitive damages as required by Hodges v. S.C. Toof & Co., 833 S.W.2d 896,

902 (Tenn. 1992). In its findings of fact and conclusions of law the trial court concluded that “the

jury properly found that Daimler Chrysler [sic] acted recklessly and that punitive damages were

warranted.” The trial court also concluded that the jury’s award of punitive damages was excessive

because there was a very large discrepancy between the punitive damages, totaling $98,000,000, and

the compensatory damages for which DCC was liable, totaling $3,750,000. Accordingly, the trial

court reduced the punitive damages to $20,000,000, a remittitur of $78,000,000. In its final order,

the trial court indicated that the plaintiffs were entitled to $13,367,345 in punitive damages for the

wrongful death of Joshua Flax and that Ms. Sparkman was individually entitled to $6,632,655 in

punitive damages for NIED.

On appeal, the Court of Appeals concluded that Ms. Sparkman’s NIED claim was subject

to the heightened proof requirements set forth in Camper v. Minor, 915 S.W.2d 437, 446 (Tenn.

1996). The Court of Appeals reversed the jury’s award of compensatory and punitive damages

related to Ms. Sparkman’s NIED claim against DCC because the plaintiffs did not satisfy the

heightened proof requirements for a “stand-alone” NIED claim. In addition, the Court of Appeals

concluded that there was not clear and convincing evidence that DCC acted recklessly or

intentionally. Accordingly, the Court of Appeals reversed the trial court’s award of all remaining

punitive damages. Finally, the Court of Appeals affirmed the trial court’s award of $5,000,000 in

compensatory damages for the wrongful death of Joshua Flax. The plaintiffs appealed the ruling of

the Court of Appeals. We granted review.

II. Negligent Infliction of Emotional Distress

We begin our analysis with Ms. Sparkman’s NIED claim. Our modern jurisprudence

concerning NIED began with Camper. In that case, the plaintiff was operating a cement truck when

a vehicle operated by the defendant pulled in front of him. The defendant was killed immediately

in the resulting collision. Although the plaintiff suffered only minor physical injuries, he filed an

NIED claim alleging that he suffered emotional injuries from viewing the defendant’s body

immediately after the accident.

We began our analysis in Camper by recognizing that the law governing NIED

is fundamentally concerned with striking a balance between two opposing objectives:

first, promoting the underlying purpose of negligence law–that of compensating

persons who have sustained emotional injuries attributable to the wrongful conduct

of others; and second, avoiding the trivial or fraudulent claims that have been thought

to be inevitable due to the subjective nature of these injuries.

Id. at 440. We then catalogued a variety of approaches used in other jurisdictions to meet these two

opposing goals. Some jurisdictions held that a plaintiff could not recover for NIED unless he or she

suffered a “physical impact” caused by the defendant’s negligent conduct. Id. Other jurisdictions

-4-

allowed a plaintiff to recover for NIED if the plaintiff suffered a “physical manifestation” of the

emotional injury. Id. at 442. Still other jurisdictions required that the plaintiff be in the “zone of

danger” created by the defendant’s negligent conduct. Id.

Prior to our decision in Camper, Tennessee applied a version of the “physical manifestation”

rule. Id. at 443; see also Memphis State Ry. Co. v. Bernstein, 194 S.W. 902, 902 (Tenn. 1917).

Unfortunately, the “physical manifestation” rule discouraged compensation for some meritorious

claims by “ignor[ing] the fact that some valid emotional injuries simply may not be accompanied

by a contemporaneous physical injury or have physical consequences.” Camper, 915 S.W.2d at 446.

Accordingly, Tennessee courts had “continually found it necessary to deviate from the ‘physical

manifestation’ rule by either formally creating exceptions to the rule or by applying the rule in a

nonrigorous fashion.” Id. at 445. To increase the fairness, clarity, and predictability of the law

governing NIED, we abandoned the “physical manifestation” rule and adopted new requirements

designed to distinguish between meritorious and frivolous cases. Id. at 446. Specifically, we held

that a plaintiff who has not suffered a physical injury must demonstrate through expert medical or

scientific proof that he or she has suffered a “severe” emotional injury. Id. We held that an

emotional injury is “severe” if “‘a reasonable person, normally constituted, would be unable to

adequately cope with the mental stress engendered by the circumstances of the case.’” Id. (quoting

Rodrigues v. State, 472 P.2d 509, 520 (Haw. 1970)). Our holding in Camper therefore balances the

goals of compensating victims and avoiding fraudulent claims by: 1) allowing a person with

emotional injuries to bring NIED claims regardless of whether he or she has suffered any physical

injury, and 2) requiring a higher degree of proof for emotional injuries under these circumstances.

In Ramsey v. Beavers, 931 S.W.2d 527, 530-31 (Tenn. 1996), we reaffirmed the principles

set forth in Camper, rejected the argument that the “zone of danger” test could be integrated into our

Camper analysis, and held that a plaintiff who saw his mother hit by a car could bring a suit for

NIED regardless of whether he was physically injured or placed in immediate danger of being

physically injured. Id. We emphasized that to prove his claim the plaintiff was required to present

expert medical or scientific evidence that he had suffered a severe emotional injury. Id. at 532. In

addition, we held that to recover for emotional injuries sustained as the result of the death or injury

of a third party a plaintiff must establish: 1) that he or she was sufficiently near the injury-causing

event to allow sensory observation of the event, and 2) that the injury was, or was reasonably

perceived to be, serious or fatal.4 Id. at 531.

We further clarified our holding in Camper in Estate of Amos v. Vanderbilt University, 62

S.W.3d 133 (Tenn. 2001). Amos involved a plaintiff who was infected with HIV during a blood

transfusion. The plaintiff received no notice of the possibility that she had been exposed to HIV.

Years later, the plaintiff gave birth to a daughter who was infected with HIV in utero. After her

4

Our opinion in Ramsey stated that the closeness of the relationship between the plaintiff and the third party

is relevant, but we stopped short of requiring plaintiffs to prove that a close relationship existed. 931 S.W .2d at 531-32;

accord Lourcey v. Estate of Scarlett, 146 S.W.3d 48, 54 (Tenn. 2004).

-5-

daughter died of an AIDS-related virus, the plaintiff was tested and learned that she had HIV. The

plaintiff and her husband filed suit for wrongful birth, negligence, and NIED.

The defendants in Amos cited Camper and argued that the plaintiff was not entitled to

recover for emotional injuries because she had failed to present expert or scientific testimony of

serious or severe emotional injury. We rejected this argument and held that “[t]he special proof

requirements in Camper are a unique safeguard to ensure the reliability of ‘stand-alone’ negligent

infliction of emotional distress claims.” Amos, 62 S.W.3d at 136-37. Because “the risk of

fraudulent claims is less . . . in a case in which a claim for emotional injury damages is one of

multiple claims for damages[,]” we held that the heightened proof requirements set forth in Camper

are inapplicable “[w]hen emotional damages are a ‘parasitic’ consequence of negligent conduct that

results in multiple types of damages.” Id. at 137. In other words, we recognized a distinction

between traditional negligence claims that include damages for emotional injuries and claims that

are based solely on NIED.

The plaintiff in Amos alleged that she had suffered emotional injuries caused by her infection

with HIV and by the subsequent infection of her daughter. Because the plaintiff’s claim of emotional

damages was not separate from her other claims of negligence, but rather was “parasitic” to those

claims, her claim was properly characterized as a negligence claim that included damages for

emotional injuries. As her claim was not based solely on NIED, we concluded that the proof

requirements of Camper were inapplicable. Id.

With this history in mind, we now turn to the facts of the instant case. At trial, the plaintiffs

failed to present expert medical or scientific proof that Ms. Sparkman suffered severe emotional

injuries. DCC filed motions for directed verdict and judgment notwithstanding the verdict, arguing

that Ms. Sparkman’s NIED claim was invalid because plaintiffs failed to meet the Camper

requirements. Plaintiffs argued that the heightened proof requirements of Camper were inapplicable

because Ms. Sparkman’s NIED claim was filed with a wrongful death claim and was therefore not

a “stand-alone” claim. The trial court agreed with the plaintiffs and upheld the jury’s verdict with

respect to Ms. Sparkman’s NIED claim.

On appeal, the plaintiffs continue to argue that the NIED claim is not a “stand-alone” claim

because the plaintiffs also brought a wrongful death suit on behalf of Joshua Flax. We disagree. It

is well settled that a wrongful death action is a claim belonging to the decedent, not the decedent’s

beneficiaries. Ki v. State, 78 S.W.3d 876, 880 (Tenn. 2002); see also Tenn. Code Ann. § 20-5-106

(Supp. 2006). “Although the living beneficiaries of the action may seek a limited recovery for their

own losses in addition to those of the decedent, the right of action itself remains one that is ‘single,

entire[,] and indivisible.’” Kline v. Eyrich, 69 S.W.3d 197, 207 (Tenn. 2002) (alteration in original)

(citations omitted) (quoting Wheeler v. Burley, No. 01A01-9701-CV-00006, 1997 WL 528801, at

*3 (Tenn. Ct. App. Aug. 27, 1997)). Accordingly, the wrongful death claim in the instant case

belongs to Joshua Flax rather than to the plaintiffs.

-6-

This case is therefore distinguishable from Amos, a case in which the plaintiff sought to

recover for emotional damages parasitic to negligence and wrongful birth claims that were personal

to the plaintiff. See Smith v. Gore, 728 S.W.2d 738, 741 (Tenn. 1987) (holding that wrongful birth

actions are actions by parents “on their own behalf”). Nothing in our opinion in Amos was intended

to allow plaintiffs to avoid the heightened proof requirements of Camper by bringing a separate

wrongful death suit on behalf of a decedent. Because Ms. Sparkman’s NIED claim is the only claim

that is personal to one of the plaintiffs, we must conclude that it is a “stand-alone” claim subject to

the requirements of Camper.

Furthermore, this case is not meaningfully distinguishable from our decision in Ramsey, a

case in which the plaintiff saw his mother killed when she was hit by a car. We held that to recover

for emotional injuries sustained as the result of the death or injury of a third party a plaintiff must

present expert medical or scientific proof of a severe emotional injury and establish proximity to the

injury-causing event and severity of the injury to the third party. Ramsey, 931 S.W.2d at 531-32.

Like the plaintiff in Ramsey, Ms. Sparkman seeks to recover for emotional injuries sustained as a

result of witnessing the death of an immediate family member. That the plaintiffs in this case

brought a wrongful death suit is not sufficient to exempt the NIED claim from the requirements set

forth in Camper and Ramsey because the filing of a wrongful death suit does nothing to demonstrate

the reliability of an NIED claim.

The plaintiffs also argue that the NIED claim is valid because Ms. Sparkman suffered minor

physical injuries in the accident but chose not to bring a claim for those injuries. This argument has

two flaws. First, the plaintiff in Camper also suffered minor injuries for which he did not file a

claim. 915 S.W.2d at 439 (quoting the plaintiff’s testimony that he suffered a scrape on his knee in

the accident). Clearly, the plaintiff’s minor injury in Camper did not prevent us from concluding that

heightened proof requirements are necessary for NIED claims. See id. at 446. Second, the emotional

injuries alleged by Ms. Sparkman are not parasitic to the minor injuries she sustained in the accident

but rather are the result of witnessing the death of her child. Even if Ms. Sparkman had chosen to

bring a claim for her minor physical injuries, her NIED claim would remain a “stand-alone” claim

because the emotional injuries sustained from witnessing the death of her child are completely

unrelated to any physical injuries she may have sustained. Of course, Ms. Sparkman would not have

been required to meet the Camper requirements to recover for any mental and emotional suffering

resulting from her own physical injuries. See Overstreet v. Shoney’s, Inc., 4 S.W.3d 694, 715 (Tenn.

Ct. App. 1999) (holding that damages for pain and suffering in a personal injury case may include

a variety of mental and emotional injuries that accompany the physical injury). When a plaintiff

suffers a physical injury there is some indication that allegations of emotional and mental injuries

resulting from that injury are not fraudulent. See Amos, 62 S.W.3d at 137. On the other hand,

having a potential claim for physical injuries does nothing to ensure the reliability of an NIED claim

relating to the emotional injuries resulting from witnessing the death or injury of a third party.

Accordingly, there is no good reason to relieve Ms. Sparkman of her burden of meeting the Camper

requirements.

-7-

Finally, the plaintiffs argue that the heightened proof requirements of Camper are

unnecessary in this case because the severity of Ms. Sparkman’s emotional injuries is obvious.

Although it is axiomatic that witnessing the death of one’s child is a horrific experience, it is not at

all obvious what impact such an event will have on any particular individual. Indeed, we constructed

the Camper requirements precisely because emotional injuries are uniquely subjective. 915 S.W.2d

at 440; Amos, 62 S.W.3d at 137. Although sympathy for a particular plaintiff may tempt us to hold

that certain circumstances “obviously” result in severe emotional injuries, we must also recognize

that such a holding would subvert the principles set forth in Camper and would likely lead to the

kind of ad hoc decisions that originally made NIED case law unpredictable and incoherent.

Furthermore, we do not believe the requirement that a severe emotional injury be proven by expert

medical or scientific evidence is unduly burdensome to those plaintiffs who have suffered legitimate

“stand-alone” emotional injuries. Accordingly, we decline to create an exception to the Camper

requirements based on the particular circumstances of this case.

Based on the foregoing considerations, we hold that Ms. Sparkman’s NIED claim was

governed by the heightened proof requirements of Camper. It is uncontested that Ms. Sparkman

failed to meet those requirements. We therefore affirm, albeit under slightly different reasoning, the

Court of Appeals’ reversal of the compensatory and punitive damage awards based on Ms.

Sparkman’s NIED claim.

III. Punitive Damages

Several issues relating to punitive damages have been hotly contested throughout the trial and

appeal of this case. DCC continues to assert three arguments against the validity of the punitive

damages awarded for the wrongful death of Joshua Flax. First, DCC argues that punitive damages

are not warranted in this case because the evidence was insufficient to support a finding of

recklessness. Second, DCC argues that the award of punitive damages is excessive in violation of

the due process standards announced by the United States Supreme Court in BMW of North

America, Inc. v. Gore, 517 U.S. 559 (1996), and State Farm Mutual Automobile Insurance Co. v.

Campbell, 538 U.S. 408 (2003). Finally, DCC argues that the trial court violated the due process

requirements of Phillip Morris USA v. Williams, ___ U.S. ___, 127 S. Ct. 1057 (2007), by allowing

the jury to consider harm to non-parties when determining the amount of punitive damages to impose

against DCC. We address each of these arguments in turn.

a. Sufficiency of Evidence Supporting Jury’s Finding of Recklessness

DCC argues that the evidence submitted by the plaintiffs was insufficient to support the

imposition of punitive damages. A verdict imposing punitive damages must be supported by clear

and convincing evidence that the defendant acted intentionally, fraudulently, maliciously, or

recklessly. Hodges v. S.C. Toof & Co., 833 S.W.2d 896, 901 (Tenn. 1992). In Hodges, we held that

evidence is clear and convincing when it leaves “no serious or substantial doubt about the

correctness of the conclusions drawn.” Id. at 901 n.3. We also held that a person acts recklessly

when “the person is aware of, but consciously disregards, a substantial and unjustifiable risk of such

-8-

a nature that its disregard constitutes a gross deviation from the standard of care that an ordinary

person would exercise under all the circumstances.” Id. at 901. The jury in this case found that there

was clear and convincing evidence that DCC’s conduct was reckless.

When this Court is called upon to review the reasonableness of a jury’s verdict, as we are in

this case, we “are limited to determining whether there is material evidence to support the verdict.”

Id. at 898. In making this determination, we do not re-weigh the evidence. Elec. Power Bd. of

Chattanooga v. St. Joseph Valley Structural Steel Corp., 691 S.W.2d 522, 526 (Tenn. 1985). Rather,

we are “required to take the strongest legitimate view of all of the evidence in favor of the verdict,

to assume the truth of all that tends to support it, allowing all reasonable inferences to sustain the

verdict, and to discard all to the contrary.” Id. The jury’s verdict must be affirmed if any material

evidence supports it. Id. Therefore, our review of this issue is limited to determining whether any

material evidence supports the jury’s conclusion that there is no serious or substantial doubt that

DCC consciously disregarded a known, substantial, and unjustifiable risk to the plaintiffs.

To determine whether there is any material evidence supporting the jury’s verdict, we must

summarize the evidence presented at trial in some detail. At trial, the plaintiffs sought to prove that

DCC had known for over twenty years that its seats were defective and unreasonably dangerous but

failed to remedy the problem or warn consumers of the danger. DCC countered by arguing that it

designed the seats to yield rearward in rear-end collisions to absorb energy from the collision and

protect the occupant of the seat. According to DCC, the Caravan design protects the greatest number

of people in the greatest number of potential accidents and using stronger seatbacks would increase

the danger to occupants of the seat. To further support its argument that its seat design was

reasonably safe, DCC repeatedly noted that its seatbacks were similar to those used by other

manufacturers and exceeded the federal regulation governing seatback strength, Federal Motor

Vehicle Safety Standard 207 (“FMVSS 207”).

As part of their effort to demonstrate that the Caravan’s seatbacks posed a substantial and

unjustifiable risk, the plaintiffs introduced the testimony of Dr. Saczalski, an expert on seat

engineering. Dr. Saczalski testified that the Caravan’s seats were defective and unreasonably

dangerous because they posed a threat to children seated behind them. His testimony was based in

part on crash testing he conducted in an attempt to recreate the accident underlying this case. During

the crash test, Dr. Saczalski used vehicles of the same make and model as those involved in the

accident and attempted to account for the weight, speed, and trajectory of each vehicle. The Caravan

used in the crash test contained dummies approximating the size and weight of Mr. Sparkman, Mr.

McNeil, Ms. Sparkman, and Joshua Flax. Dr. Saczalski replaced the driver’s seat of the Caravan

with a seat from a 1996 Chrysler Sebring, a DCC vehicle that had seats with backs approximately

five times stronger than the seats used in the Caravan. Dr. Saczalski placed the Sebring seat in the

crash test vehicle to demonstrate how a stronger seatback would perform under forces equivalent to

those suffered by the Caravan in the actual accident.

Consistent with the circumstances of the actual accident, videos of the crash test show that

the front passenger’s seat yielded rearward allowing the McNeil surrogate’s head to impact the head

-9-

of the Joshua Flax surrogate. The Sebring seat also yielded rearward but to a far lesser degree.

Significantly, the Sebring seat did not substantially encroach upon the seating area behind it. Dr.

Saczalski concluded from the crash test that Joshua Flax would have survived the accident without

serious injury had the Caravan been equipped with seats with backs as strong as those of the Sebring

seat. Contrary to DCC’s assertion that stronger seatbacks impose greater dangers to their occupants

in rear-end collisions, the crash test dummy in the stronger Sebring seat experienced less head and

neck acceleration than the dummy in the Caravan seat.

Dr. Saczalski also testified regarding several other crash tests he performed in which Sebring

seats were placed side-by-side with other DCC minivan seats. These tests also demonstrated that

DCC minivan seats have the capacity to cause injury to children seated behind them. The test results

support the view that Sebring seats do not pose the same threat because they do not encroach upon

the passenger space behind them. Furthermore, Dr. Saczalski testified that the dummy-occupants

of the stronger Sebring seats tended to experience less acceleration to the head and neck than the

dummy-occupants of weaker seats.

The plaintiffs also made a considerable effort to demonstrate that DCC was aware that the

Caravan seats were defective and unreasonably dangerous for at least twenty years. The minutes

from a DCC Engineer Safety Committee meeting dated December 10, 1980, appear to contain the

first acknowledgment that yielding seatbacks could be a potential problem. In the meeting it was

noted that the seatbacks had yielded to some degree in every crash test and that “improvements could

be made, but would require development costs and a piece penalty would result.” The Engineer

Safety Committee did not make any recommendation to improve seatback strength because the seats

performed as well as those of DCC’s competitors, complied with federal requirements, and had not

been demonstrated “to be a significant injury producing problem.” Videos of crash testing

performed by DCC confirm that in rear-impact collisions the seats yielded into the occupant space

behind them. In addition, plaintiffs presented documentation showing that in at least one crash test

conducted in 1989 the front seats were braced to prevent the seatbacks from impacting equipment

occupying the back seat.

Although the minutes from the 1980 meeting indicate that there was no evidence that the

seats were a “significant injury producing problem,” DCC soon began to receive new information.

According to an employee in DCC’s customer relations department, during the mid-1980s, DCC

began to receive reports of children injured by yielding seatbacks in rear-end collisions. DCC’s

records contained documentation of several rear-end collisions in which a yielding seatback caused

a child to suffer skull or facial fractures. Other injuries sustained by children seated behind yielding

seatbacks were also reported to DCC. In spite of these reports, DCC did not issue any warning to

customers and continued to advertise the Caravan as a vehicle specifically designed to protect

children.

The most significant testimony regarding DCC’s knowledge of the danger presented by the

Caravan seats was provided by Paul Sheridan, a former DCC employee. During his employment

with DCC, Mr. Sheridan served as the chair of the Minivan Safety Leadership Team (“MSLT”), a

-10-

committee formed to address safety concerns in DCC’s minivans. The committee was comprised

of persons from DCC’s safety, engineering, marketing, sales, and design departments. One of the

many safety issues the MSLT was formed to address was the issue of seatback strength. According

to Mr. Sheridan, the MSLT had available to it complaints regarding injuries caused by yielding

seatbacks. At a March 16, 1993, committee meeting, members of the MSLT reached a consensus

that it was unacceptable for seats to yield rearward into the passenger space behind them and that

the seats were inadequate to protect customers. After the meeting, Mr. Sheridan distributed the

minutes of the meeting to various DCC executives. Some time thereafter, Ronald Zarowitz, a

member of the MSLT representing DCC’s safety office, instructed Mr. Sheridan to retrieve the

minutes of the meeting and destroy them. Mr. Zarowitz informed Mr. Sheridan that this order came

from Francois Castaing, the head of the engineering department. Mr. Sheridan retrieved the minutes

as instructed, but he retained two copies in his office.

After the March 1993 meeting, Mr. Sheridan decided to investigate the seatback issue further.

To this end, Mr. Sheridan met with an engineer responsible for seat design and requested the seat

design specifications that discussed how the seats were designed to yield. According to Mr.

Sheridan, the engineer “didn’t know what [he] was asking for” but provided the design specifications

of the seats. These specifications did not state that the seats were designed to yield. In fact, Mr.

Sheridan testified that he never heard any engineer state that seatbacks were designed to yield

rearward as a safety precaution. In September 1994, Mr. Sheridan told his supervisor that he was

going to go to regulators with his concerns about the minivan seatbacks. In November 1994, the

MSLT was disbanded at the direction of Ted Cunningham, the executive with authority over minivan

operations. Mr. Sheridan was fired on December 27, 1994, and the minutes from the March 1993

MSLT meeting and the seat design specifications were confiscated from his office.5

We find little support in the record for Justice Koch’s speculation that Mr. Sheridan’s

testimony “may very well reflect DaimlerChrysler’s over-reaction to the Sixty Minutes story and the

existence of some internal dissension regarding how best to respond to the concerns about car seat

safety raised by the story.” In fact, this characterization of Mr. Sheridan’s testimony appears to have

been rejected by the jury, which heard his testimony and was charged with resolving issues of

credibility. Moreover, DCC presented no testimony that the formation of the MSLT was an “over-

reaction,” and it is clear from Mr. Sheridan’s testimony that he believed the MSLT was necessary

to address serious safety concerns. DCC’s efforts to destroy the recommendations produced by the

MSLT are a further indication of DCC’s awareness of the seat-back problem and its determination

to hide the problem rather than solve it. In our minds, this represents more than “some internal

dissension regarding how best to respond to the concerns about car safety.”

Justice Koch’s efforts to discount Mr. Sheridan’s testimony are inconsistent with our standard

of review on appeal. The jury apparently accredited much of Mr. Sheridan’s testimony, and, as we

have stated, we are required to view his testimony in the light most favorable to the jury’s verdict

5

Those documents are not included in the record before us. The plaintiffs allege that the documents were not

produced during discovery.

-11-

and assume the truth of his assertions that support the jury’s verdict. Elec. Power Bd. of

Chattanooga, 691 S.W.2d at 526. We therefore must assume that Mr. Sheridan was truthful when

he denied leaking confidential information to Auto World magazine. We must also make the

reasonable inference that Mr. Sheridan in fact was fired because he threatened to go to regulators

with his safety concerns. In addition, whether Mr. Sheridan has been excluded from testifying in

other cases is irrelevant to our review. The trial court denied DCC’s motion to exclude Mr.

Sheridan’s testimony, and DCC has not appealed that aspect of the trial court’s ruling. The actions

of another court have no impact on our review of the testimony accredited by the jury.

The plaintiffs also sought to demonstrate that compliance with FMVSS 207 was insufficient

to make the Caravan seats reasonably safe. A seat engineer employed by DCC testified that FMVSS

207 requires “inadequate seat strength to insure that the seat does not fail when the car is subject to

severe rear impact.” In addition, Mr. Sheridan testified that members of the MSLT agreed that

compliance with FMVSS 207 was insufficient to ensure safety of consumers. Furthermore, both of

DCC’s experts on seat design agreed that compliance with FMVSS 207 alone is inadequate to

protect passengers.

Finally, the plaintiffs argued that stronger seatbacks would not result in greater injuries to

occupants of the seats. Specifically, the plaintiffs claimed that the Sebring seat, which was

approximately five times stronger than the Caravan seat, was a reasonably safe seat. The results of

Dr. Saczalski’s crash testing provide some evidence that the Sebring seat offered a reasonable level

of protection to its occupants. In addition, one of DCC’s experts on seatback engineering agreed that

the Sebring seat was a reasonably safe seat.

In summary, the jury’s finding that the Caravan seats posed a substantial and unjustifiable

risk to consumers was supported by: 1) expert testimony that the seats were defective and

unreasonably dangerous; 2) crash tests demonstrating that the yielding seatbacks consistently

encroached upon the occupant space behind them; 3) Mr. Sheridan’s testimony that safety officials

and engineers employed by DCC believed that the Caravan’s seats were unacceptably dangerous;

and 4) crash test evidence and expert testimony that Joshua Flax would not have been killed had a

stronger seat been in place. The jury’s finding that DCC consciously disregarded the risks posed by

the Caravan seats was supported by: 1) minutes of DCC meetings noting that seats yielded; 2) DCC

crash tests demonstrating that seats consistently encroached upon the passenger space behind them;

3) DCC records of injuries caused by yielding seatbacks; and 4) Mr. Sheridan’s testimony that

executives ignored the MSLT’s warning that the seatbacks were unacceptably dangerous. We

conclude that this evidence adequately supports the jury’s conclusion that there is no serious or

substantial doubt that DCC consciously disregarded a known, substantial, and unjustifiable risk to

the plaintiffs. The evidence that DCC executives failed to heed the warnings of the MSLT and

ordered the destruction of the committee’s findings is particularly compelling. Not only did DCC

fail to warn customers or redesign its product, DCC hid the evidence and continued to market the

Caravan as a vehicle that put safety first. Because the jury’s verdict is supported by clear and

convincing material evidence, we must affirm the jury’s finding of recklessness. Elec. Power Bd.

of Chattanooga, 691 S.W.2d at 526.

-12-

DCC’s argument that risks associated with the Caravan seats were justified by the need for

the seat to absorb energy from the collision and protect seat occupants is of no avail. This argument

was presented to the jury, and the jury was apparently unconvinced by it. The jury could have

reasonably accredited Mr. Sheridan’s testimony that the seats were not intentionally designed to yield

as a safety mechanism. The jury also could have reasonably concluded from testimony regarding

the Sebring seat that seats need not yield as dramatically as the Caravan seats to protect seat

occupants. DCC’s argument that there is an ongoing debate regarding the optimum level of seatback

strength is also without merit. The jury could have reasonably concluded that such a debate exists

and simultaneously found that the Caravan’s seats were weak enough to fall outside the range of

reasonable debate.

With regard to DCC’s proposed justification, Justice Koch fails to give proper deference to

the jury’s conclusions. He concludes that a “genuine principled debate” concerning the proper

seatback strength led DCC to design “the front seats of the minivan to yield in a controlled manner

in the event of a rear impact.” Whether the seats were designed to yield “in a controlled manner”

was contested at trial. The jury, apparently convinced by the accident reconstruction, the expert

testimony, DCC’s crash tests, and Mr. Sheridan’s testimony, concluded that the manner in which the

seats yielded was unreasonably dangerous and that DCC recklessly disregarded the danger to its

customers. While Justice Koch may disagree with that conclusion, this Court is not free to reweigh

the evidence or second-guess the jury’s conclusions when they are supported by material evidence.

We are also unconvinced by DCC’s arguments that compliance with federal regulations and

custom within an industry should bar the recovery of punitive damages. It is true that compliance

with FMVSS 207 entitled DCC to a rebuttable presumption that its product was not unreasonably

dangerous. Tenn. Code Ann. § 29-28-104. It is equally true, for the reasons stated above, that the

evidence in this case thoroughly rebutted that presumption. Tennessee Code Annotated section

29-28-104 was designed “‘to give refuge to the manufacturer who is operating in good faith and [in]

compliance of what the law requires him to do.’” Tuggle v. Raymond Corp., 868 S.W.2d 621, 625

(Tenn. Ct. App. 1992) (alteration in original). The statute was not designed to provide immunity

from punitive damages to a manufacturer who is aware that compliance with a regulation is

insufficient to protect users of the product. While evidence of compliance with government

regulations is certainly evidence that a manufacturer was not reckless, it is not dispositive. See

O’Gilvie v. Int’l Playtex, Inc., 821 F.2d 1438, 1446 (10th Cir. 1987); Silkwood v. Kerr-McGee

Corp., 769 F.2d 1451, 1457-58 (10th Cir. 1985); Dorsey v. Honda Motor Co., 655 F.2d 650, 656 (5th

Cir. 1981). To hold otherwise would create an overly inflexible rule that would allow some

manufacturers knowingly engaged in reprehensible conduct to escape the imposition of punitive

damages.

Similarly, if a manufacturer knows that a common practice in an industry presents a

substantial and unjustifiable risk to consumers, then compliance with the common practice is not an

absolute bar to the recovery of punitive damages. Cf. Surles ex rel. Johnson v. Greyhound Lines,

Inc., 474 F.3d 288, 300-01 (6th Cir. 2007) (applying Tennessee law and concluding that compliance

with federal regulations and common industry practices is evidence of the standard of care but does

-13-

not conclusively establish the standard of care in negligence cases). Evidence that a manufacturer

consciously disregarded substantial and unjustifiable risks to the public can, in some rare cases,

overcome evidence that the manufacturer’s practice was common in the industry. This is such a

case. Because the jury could have reasonably concluded from the evidence presented that DCC was

aware that compliance with the FMVSS 207 and the industry standard for seat design was

insufficient, we hold that punitive damages were not barred in this case.

b. Due Process Concerns and the Excessiveness of the Punitive Damage Award

Having concluded that punitive damages were warranted in this case, we now review whether

the size of the punitive damage award is excessive in violation of the due process standards

announced by the United States Supreme Court in Gore and Campbell. We begin our analysis of this

issue by reviewing the United States Supreme Court’s punitive damage jurisprudence.

In Gore, the United States Supreme Court was called upon to determine the constitutionality

of a punitive damage award. The Court concluded that due process requires that “a person receive

fair notice not only of the conduct that will subject him to punishment, but also of the severity of the

penalty that a State may impose.” Gore, 517 U.S. at 574. Accordingly, the Court adopted three

guideposts for determining whether a defendant has adequate notice of the magnitude of the sanction

that may be imposed. The first and most important guidepost is the reprehensibility of the

defendant’s conduct. Id. at 575. The Court indicated that the presence of violence, deceit, reckless

disregard for the safety of others, or repeated misconduct may be aggravating factors that increase

the reprehensibility of the defendant’s conduct. Id. at 575-76. The second guidepost is the ratio

between the punitive damage award and the actual harm suffered by the plaintiff. Id. at 580.

Although the Court declined to adopt any strict mathematical formula, it repeated the suggestion

from a previous case that “a punitive damages award of ‘more than 4 times the amount of

compensatory damages’ might be ‘close to the line’” of constitutional impropriety. Id. at 581-82

(quoting Pac. Mut. Life Ins. Co. v. Haslip, 499 U.S. 1, 23-24 (1991)). The final guidepost requires

courts to compare the punitive damage award to civil or criminal penalties that could be imposed for

similar conduct. “[A] reviewing court engaged in determining whether an award of punitive

damages is excessive should ‘accord ‘substantial deference’ to legislative judgments concerning

appropriate sanctions for the conduct at issue.’” Id. at 583 (quoting Browning-Ferris Indus. of Vt.,

Inc. v. Kelco Disposal, Inc., 492 U.S. 257, 301 (1989) (O’Connor, J., concurring in part and

dissenting in part)). These legislative judgments are relevant because they provide defendants with

notice of the severity of the penalty that may be imposed upon them. See id. at 584.

The United States Supreme Court next considered the due process requirements for punitive

damages in Campbell. The Court again observed that the reprehensibility of the defendant’s conduct

is the most important guidepost. Campbell, 538 U.S. at 419. In an effort to provide guidance to

lower courts, the Court stated that courts should determine reprehensibility

by considering whether: the harm caused was physical as opposed to economic; the

tortious conduct evinced an indifference to or a reckless disregard of the health or

-14-

safety of others; the target of the conduct had financial vulnerability; the conduct

involved repeated actions or was an isolated incident; and the harm was the result of

intentional malice, trickery, or deceit, or mere accident.

Id. The Court further stated, “The existence of any one of these factors weighing in favor of a

plaintiff may not be sufficient to sustain a punitive damages award; and the absence of all of them

renders any award suspect.” Id. With regard to the second guidepost, the Court stated, “[I]n

practice, few awards exceeding a single-digit ratio between punitive and compensatory damages, to

a significant degree, will satisfy due process.” Id. at 425. In addition, “[w]hen compensatory

damages are substantial, then a lesser ratio, perhaps only equal to compensatory damages, can reach

the outermost limit of the due process guarantee.” Id. The Court then qualified its previous

statement by observing that “[t]he precise award in any case, of course, must be based upon the facts

and circumstances of the defendant’s conduct and the harm to the plaintiff.” Id. Finally, when

discussing the third guidepost, the Court held that

[t]he existence of a criminal penalty does have bearing on the seriousness with which

a State views the wrongful action. When used to determine the dollar amount of the

award, however, the criminal penalty has less utility. Great care must be taken to

avoid use of the civil process to assess criminal penalties that can be imposed only

after the heightened protections of a criminal trial have been observed, including, of

course, its higher standards of proof. Punitive damages are not a substitute for the

criminal process, and the remote possibility of a criminal sanction does not

automatically sustain a punitive damages award. Id. at 428.

Unlike the deferential standard of review employed when reviewing a jury’s factual conclusions, we

conduct a de novo review of the amount of a punitive damages award to determine whether the

award meets due process requirements in light of the three guideposts. Id. at 418.

Having reviewed the applicable United States Supreme Court precedents, we now turn to the

application of the principles set forth therein. The evidence in this case clearly demonstrates that

DCC’s conduct was reprehensible. Obviously, the harm suffered in this case was physical rather

than economic. The death of a child is undoubtedly a tragic experience that is far more serious than

a mere economic loss. Furthermore, as we have summarized above, DCC’s conduct evinces a

conscious disregard for the safety of others. In addition, DCC deceitfully covered up evidence of

the deficiencies of its seat design while simultaneously advertising the Caravan as a vehicle that put

children’s safety first. Finally, DCC’s wrongdoing was not an isolated incident because DCC had

knowledge of the danger its seats posed to the public for years and yet continued to sell its vehicles

in an unreasonably dangerous condition throughout the State of Tennessee. We therefore conclude

that under this first, most important guidepost DCC had fair notice that its conduct could subject it

to a severe penalty.

We now turn to the second guidepost, the ratio between the punitive damages and

compensatory damages. The trial court in this case remitted the punitive damages for the wrongful

-15-

death of Joshua Flax to $13,367,345.6 We must compare this punitive damage award to the

$2,500,000 in compensatory damages for which DCC is liable for the wrongful death of Joshua Flax.

The ratio between these two awards is 1 to 5.35. This ratio is not clearly impermissible because it

does not exceed a single digit ratio. See Campbell, 538 U.S. at 425. There is, however, some doubt

as to the propriety of a ratio of 1 to 5.35 because the United States Supreme Court has suggested that

a ratio of more than 1 to 4 approaches the outer limits of constitutionality. Id.; Gore, 517 U.S. at

581. The Court has also suggested that a ratio of 1 to 1 may be all that is permissible in cases where

compensatory damages are “substantial.” See Campbell, 538 U.S. at 425. None of these ratios,

however, present “rigid benchmarks,” and the United States Supreme Court has thus far declined to

adopt any fixed mathematical formula to determine the appropriateness of punitive damages. Id.

Instead, the Court has held that “[t]he precise award in any case, of course, must be based upon the

facts and circumstances of the defendant’s conduct and the harm to the plaintiff.” Id.

In light of the first two guideposts, we believe that a ratio of 1 to 5.35 would be warranted

in this case. Although the United State Supreme Court has made no effort to demonstrate when

damages are “substantial,” we do not believe that an award of $2,500,000 is so large as to require

a ratio of 1 to 1. Furthermore, a punitive damage award of $13,367,345 is consistent with the

concept that the reprehensibility of a defendant’s conduct is the most important of the due process

guideposts and is justified by DCC’s long-term pattern of conduct that resulted in severe injuries to

the plaintiffs and showed a conscious disregard for the safety of Tennessee citizens. Accordingly,

in light of the first two guideposts we would hold that a punitive damage award approaching the

maximum ratio permitted by the due process clause is appropriate.

The third guidepost set forth in Gore seems to compel a dramatically different conclusion.

The statute that most closely expresses the Tennessee General Assembly’s judgment concerning the

wrongfulness of DCC’s conduct is the reckless homicide statute codified at Tennessee Code

Annotated section 39-13-215 (2006). According to that statute, reckless homicide is “a reckless

killing of another.” Tenn. Code Ann. § 39-13-215. The meaning of the word “reckless” as it is used

in that statute is identical to the meaning of “reckless” in a punitive damage context. Compare

Hodges, 833 S.W.2d at 901, with Tenn. Code Ann. § 39-11-302(c) (2006). Because DCC’s reckless

conduct resulted in the death of Joshua Flax, reckless homicide is the criminal act most analogous

to DCC’s conduct.7 The maximum statutory punishment for corporations that commit reckless

homicide is a fine of $125,000. Tenn. Code Ann. § 40-35-111(c)(4) (2006).

Pursuant to the holding of the United States Supreme Court, we must accord “substantial

deference” to the General Assembly’s decision that $125,000 is an appropriate sanction against

corporations guilty of reckless homicide. Gore, 517 U.S. at 583. Furthermore, we must “avoid use

6

Having invalidated the trial court’s award of compensatory and punitive damages based on NIED, we need

only discuss the punitive damages arising out of the wrongful death claim.

7

W e express no opinion concerning whether DCC could actually be prosecuted for reckless homicide under

Tennessee Code Annotated section 39-11-404 (2006). It is sufficient that the statutory definition of reckless homicide

encompasses the conduct of DCC.

-16-

of the civil process to assess criminal penalties that can be imposed only after the heightened

protections of a criminal trial have been observed.” Campbell, 538 U.S. at 428. Although the

United States Supreme Court has never held that the third guidepost is dispositive, it appears that

under this guidepost $125,000 would be the maximum punitive damage award that could be imposed

in this case. Arguably, this is because DCC never had notice that it could be held liable for an

amount greater than $125,000.8 Clearly, the result recommended by the third guidepost is

dramatically at odds with the result suggested by the first two. We are unfortunately left with little

guidance as to how to resolve this discrepancy because both Gore and Campbell are cases in which

all of the guideposts suggest the same result. Other courts have experienced similar frustrations

when attempting to apply the third guidepost, and some have chosen to ignore the third guidepost

altogether. See, e.g., In re Exxon Valdez, 490 F.3d 1066, 1094 (9th 2007) (noting that if the Court

of Appeals for the Ninth Circuit mentions the third guidepost at all, it does not review the amounts

of legislative penalties but determines “whether or not the misconduct was dealt with seriously under

state civil or criminal laws”); Willow Inn, Inc. v Pub. Serv. Mut. Ins. Co., 399 F.3d 224, 237-38 (3d

Cir. 2005) (noting the difficulty courts have in applying the third guidepost and declining to overturn

a punitive damage award on that basis alone).

Although we are somewhat unsure how to reconcile the third guidepost with the first two,

we are inclined to give the first two guideposts considerably more weight. The Unites States

Supreme Court has held that the first guidepost is the most important and has never stated that the

third guidepost is dispositive. Furthermore, we are unaware of any state or federal case that has

invalidated a punitive damage award solely because the award was greater than that contemplated

by statutory penalties. In addition, the trial court’s award in this case is far less drastic than the

awards rejected in Gore and Campbell, which were 1,000 and 14,500 times greater, respectively,

than the maximum civil or criminal penalty. See Campbell, 538 U.S. at 428; Gore, 517 U.S. at 584.

Finally, we do not believe that a punitive damage award of $125,000 would adequately punish DCC

or deter future instances of similar conduct. For these reasons, we conclude that a punitive damage

award of $13,367,345 is constitutionally permissible in this case.

c. Due Process Concerns and Harm to Non-Parties

DCC also contends that its right to due process was violated because the jury was allowed

to punish DCC for harm suffered by persons who were not parties to the action. In support of this

argument, DCC cites the United States Supreme Court’s recent decision, Philip Morris. In Philip

Morris, the Court held that trial courts must, upon request, provide assurance that juries are not

8

W e find this reasoning somewhat peculiar considering that our decision in Hodges clearly set forth both the

conditions under which a defendant could be held liable for punitive damages and the factors that would determine the

amount of punitive damages available. See Hodges, 833 S.W .2d at 901-02. Although those standards were necessarily

imprecise, our decision in that case would appear to be sufficient to provide DCC with notice that consciously

disregarding the safety of Tennessee citizens could subject it to a considerably large punitive damage award.

-17-

allowed to punish defendants for harm caused to nonparties. Id. at 1065.9 In the present case, DCC

requested that the jury be instructed that it could not punish DCC for harm suffered by nonparties,

but the trial court declined to give this instruction. Unfortunately, DCC did not question the

rejection of its proposed jury instruction in the Court of Appeals. DCC now seeks to resurrect this

issue before this Court. Litigants who hope to have an issue heard by this Court must first present

that issue to the intermediate appellate court. See Brown v. Crown Equip. Corp., 181 S.W.3d 268,

281 n.5 (Tenn. 2005); Va. & Sw. R.R. Co. v. Sutherland, 197 S.W. 863, 864 (Tenn. 1917).

Accordingly, we do not reach the issue of whether the trial court erred by failing to instruct the jury

not to punish DCC for harm suffered by nonparties.

IV. Validity of Plaintiffs’ Post-Sale Failure to Warn Claim

In their complaint, the plaintiffs asserted a claim based on DCC’s failure to warn consumers

that the Caravan’s seatbacks posed a danger to children placed behind them. Prior to trial, the

plaintiffs filed a trial brief clarifying that they were attempting to bring two separate failure to warn

claims. The first claim is a traditional failure to warn claim alleging that DCC failed to provide a

warning prior to or at the time the Caravan was sold. Tennessee courts have long held that a

manufacturer may be held strictly liable for failing to warn consumers of the dangers of a particular

product at the time of sale. Whitehead v. Dycho Co., 775 S.W.2d 593, 596 (Tenn. 1989); Trimble

v. Irwin, 441 S.W.2d 818, 821 (Tenn. Ct. App. 1968). The General Assembly has also

acknowledged that a failure to warn claim is a valid basis for a product liability action. Tenn. Code

Ann. § 29-28-102(6) (2000). Accordingly, the trial court permitted the plaintiffs to proceed with the

traditional failure to warn claim, and DCC has not appealed the trial court’s ruling on that issue.

The plaintiffs’ second failure to warn claim is more problematic. In their trial brief, the

plaintiffs asserted that DCC should also be held liable for failing to warn the plaintiffs of the

condition of the seatbacks after the Caravan was sold. Plaintiffs argued their second claim is what

is commonly referred to as a “post-sale failure to warn” claim,10 a claim that has not been previously

recognized in Tennessee. Irion v. Sun Lighting, Inc., No. M2002-00766-COA-R3-CV, 2004 WL

746823, at *17 (Tenn. Ct. App. Apr. 7, 2004). Under the assumption that their second claim was

a post-sale failure to warn claim, the plaintiffs argued that the trial court should join the jurisdictions

that recognize the post-sale failure to warn claims and adopt the post-sale failure to warn provisions

of the Restatement (Third) of Torts. See Restatement (Third) of Torts: Products Liability § 10

(1998). The trial court was persuaded by the plaintiffs’ arguments and allowed the plaintiffs to

9

The Court did attempt to clarify that injuries suffered by nonparties are relevant to demonstrate the

reprehensibility of a defendant’s conduct. Id. at 1064. As the Court stated, “conduct that risks harm to many is likely

more reprehensible than conduct that risks harm to only a few.” Id. at 1065. Upon motion by the parties, trial courts

are required to instruct the jury that it may consider harm to nonparties to determine reprehensibility but should not

directly punish defendants for harm to nonparties.

10

For reasons that are explained below, we do not believe plaintiffs’ second failure to warn claim is properly

characterized as a post-sale failure to warn claim. Accordingly, we refer to their cause of action as the “second failure

to warn claim” or the “second claim.”

-18-

present evidence and argument at trial in support of their second failure to warn claim. At the

conclusion of the trial, the jury found the defendants liable on the plaintiffs’ second failure to warn

claim.

DCC contends that the trial court erred in recognizing the post-sale failure to warn claim.

We agree. Although different states apply the doctrine differently, the vast majority of courts

recognizing post-sale failure to warn claims agree that a claim arises when the manufacturer or seller

becomes aware that a product is defective or unreasonably dangerous after the point of sale and fails

to take reasonable steps to warn consumers who purchased the product. See, e.g., Lovick v. Wil-

Rich, 588 N.W.2d 688, 693 (Iowa 1999); Patton v. Hutchinson Wil-Rich Mfg. Co., 861 P.2d 1299,

1313 (Kan. 1993); Owens-Illinois, Inc. v. Zenobia, 601 A.2d 633, 645-46 (Md. 1992); Comstock v.

Gen. Motors Corp., 99 N.W.2d 627, 634 (Mich. 1959); see also Douglas R. Richmond, Expanding

Products Liability: Manufacturers’ Post-Sale Duties to Warn, Retrofit and Recall, 36 Idaho L. Rev.

7, 18 (1999). Accordingly, courts apply the traditional failure to warn claim when a manufacturer

or seller had knowledge of a defect at the time of sale and apply the post-sale failure to warn claim

when a manufacturer or seller learns of the defect after the time of sale.11 Victor E. Schwartz, The

Post-Sale Duty to Warn: Two Unfortunate Forks in the Road to a Reasonable Doctrine, 58 N.Y.U.

L. Rev. 892, 893 (1983).

Unlike plaintiffs in post-sale duty to warn cases, the plaintiffs in this case do not allege that

DCC discovered problems with the seatbacks after the time of sale. On the contrary, the theory of

the plaintiffs’ case was that DCC had knowledge that the seats were defective and unreasonably

dangerous as early as the 1980s. Furthermore, DCC does not deny that it had knowledge of the

performance of its seats at the time of sale but argues that the seats functioned in a non-defective and

reasonably safe manner. There is therefore no dispute regarding DCC’s knowledge at the time of

sale of the Caravan. Although the plaintiffs allege that DCC continued to receive notice that its

product was dangerous after the sale, they do not allege that DCC received any new information

during this period. Accordingly, this case does not present the facts necessary to allow us to consider

the merits of recognizing post-sale failure to warn claims. Rather, the plaintiffs’ allegation that DCC

was negligent in failing to warn the plaintiffs after the sale is an attempt to impose liability a second

time for what is essentially the same wrongful conduct. If a defendant negligently fails to warn at

the time of sale, that defendant does not breach any new duty to the plaintiff by failing to provide

a warning the day after the sale. Instead, the defendant merely remains in breach of its initial duty.

For these reasons, we conclude that the trial court erred by adopting and applying the post-sale

failure to warn claim in this case. We express no opinion, however, as to the merits of recognizing

that cause of action in an appropriate case.

11

The distinction between the two causes of action is important because the burden of issuing a warning is

much greater once the product has left the control of the manufacturer or seller. Restatement (Third) of Torts: Products

Liability § 10 cmt. a. Therefore, jurisdictions that allow post-sale failure to warn claims generally consider the difficulty

of identifying and communicating with product users when determining whether the manufacturer or seller acted

reasonably. See id.; Lovick, 588 N.W .2d at 695-96. These difficulties are generally not an issue in traditional failure

to warn claims.

-19-

DCC claims the trial court’s error was prejudicial to DCC in two ways. First, DCC claims

that due process concerns are raised by allowing the jury to base its recklessness determination on

a previously unrecognized cause of action. Essentially, DCC argues that it did not have notice that

it could be punished for failing to issue a warning after the date of sale. See Gore, 517 U.S. at 574

(holding that a defendant is entitled to fair notice of “the conduct that will subject him to

punishment”). Although the jury did find DCC liable for the post-sale duty to warn claim, it also

found DCC liable on three other grounds—designing, manufacturing, and selling the Caravan with

defective seats; designing, manufacturing, and selling the Caravan with unreasonably dangerous

seats; and failing to warn the plaintiffs at the time of sale. There was sufficient evidence of

recklessness related to these three claims from which a reasonable jury could have determined that

punitive damages were warranted. Furthermore, in the second phase of the trial, the trial court

instructed the jury that it was not to base its award of punitive damages on the post-sale failure to

warn claim. In spite of this instruction, the jury awarded $98,000,000 in punitive damages. The

jury’s belief that the three valid claims warranted such a substantial award is powerful evidence that

the decision to impose punitive damages was not based upon the post-sale failure to warn claim.

Furthermore, we are similarly unconvinced that the jury based the wrongful death award on the post-

sale failure to warn claim. Under the circumstances of this case, the three valid claims were

sufficient to support a wrongful death award of $5,000,000. Accordingly, we find this argument to

be without merit.

Second, DCC claims that the post-sale duty to warn claim permitted the admission of

evidence that otherwise would have been deemed irrelevant. Specifically, DCC argues that the

evidence of other similar incidents occurring after the date of sale would not have been admissible.

Indeed, the plaintiffs acknowledged at trial and in their response to DCC’s Motion for Judgment

Notwithstanding the Verdict and New Trial that the other similar incidents were tendered and

admitted only to prove that DCC had notice of the condition of the seats. The jury was also

instructed that it could consider the other similar incidents only for the purpose of showing that DCC

had notice of the seat’s condition. In their post-trial motions and responses, the parties appeared to

agree that the documents supporting the other similar incidents would have been inadmissible

hearsay if offered to prove that the seats were defective or unreasonably dangerous. Clearly incidents

that occurred after the date the plaintiffs purchased the Caravan could not have provided DCC with

notice that it should provide a warning at the time the Caravan was sold. It therefore appears that

the trial court admitted evidence of the post-sale similar incidents to show notice with respect to the

plaintiffs’ second failure to warn claim. We agree that there would have been no valid reason to

admit the post-sale similar incidents if the trial court had not recognized the plaintiffs’ second failure

to warn claim. Because we hold that the trial court should not have recognized this claim, the trial

court erred in admitting evidence of the twenty-five other similar incidents that occurred after the

Caravan was purchased in May 1998.

Our inquiry does not end here. DCC is entitled to reversal of the jury’s verdict only if the

trial court’s error would have “more probably than not affected the judgment or would result in

prejudice to the judicial process.” Tenn. R. App. P. 36(b); accord Cumulus Broad., Inc. v. Shim, 226

S.W.3d 366, 375 (Tenn. 2007). “The greater the amount of evidence of guilt, the heavier the burden

-20-

on the defendant to demonstrate that a non-constitutional error involving a substantial right more

probably than not affected the outcome of the trial.” State v. Rodriguez, ___ S.W.3d ___, ___

(Tenn. 2008).

Although the jury heard evidence of twenty-five post-sale similar incidents, the trial court

instructed the jury that it could consider that evidence only for the purpose of determining whether

DCC had notice of the condition of the seats. We presume that the jury followed the trial court’s

instruction and did not consider the other similar incidents for purposes of determining whether the

seats were unreasonably dangerous. State v. Williams, 977 S.W.2d 101, 106 (Tenn. 1998). We

therefore conclude that the trial court’s instruction significantly reduced the danger of prejudice to

DCC. In addition, the trial judge’s remittitur of the punitive damages award also limited the danger

that the evidentiary error affected the judgment in this case.

Most importantly, there was a wealth of evidence supporting the jury’s verdict. There was

testimony that DCC had received notice of children injured by yielding seatbacks as early as the mid-

1980s. DCC’s own crash test videos demonstrated that seatbacks consistently yielded into the

passenger space behind them in rear-end collisions. Mr. Sheridan testified that the MSLT informed

DCC executives that the seats were dangerous. Finally, the plaintiffs introduced twelve similar

incidents that occurred before the date of sale. Of those twelve, three incidents involved a child

suffering skull or facial fractures as a result of a yielding seat. Three others involved children

suffering other injuries from yielding seatbacks. The jury’s verdict is amply supported by this

properly admitted evidence. In light of the wealth of evidence supporting the jury’s verdict, we

conclude that the twenty-five other similar incidents that were improperly admitted were not so

significant as to affect the jury’s verdict. Accordingly, we conclude that the trial court’s decision

to admit the post-sale other similar incidents did not prejudice the judicial process or more probably

than not affect the judgment.

We are not indifferent to Justice Koch’s concerns about the volume of improperly admitted

evidence and the potential for prejudice when admitting other similar incidents. As we have stated,

however, the proof of DCC’s recklessness is so powerful that the jury was probably not affected by

the trial court’s error. Justice Koch has a very different view of the evidence in this case, and it is

therefore unsurprising that his dissent expresses a greater estimation of the impact of the trial court’s

error.

V. Miscellaneous Rulings of the Trial Court

DCC also argues that it was prejudiced by various other rulings of the trial court.

Specifically, DCC argues that the trial court abused its discretion by admitting the other similar

incidents that occurred prior to the sale of the Caravan, excluding accident data proffered by DCC,

and failing to grant a new trial as a sanction for the trial court’s determination that plaintiffs abused

the discovery process. DCC also argues that the absence of a valid ad damnum clause in plaintiffs’

complaint should bar any award to the plaintiffs. For the reasons stated by the Court of Appeals, we

conclude that each of these arguments is without merit.

-21-

VI. Conclusion

We hold that Ms. Sparkman’s NIED claim is a “stand-alone” claim in spite of the fact that

she simultaneously brought a wrongful death claim. Therefore, Ms. Sparkman’s NIED claim should

have been supported by expert medical or scientific proof of a severe emotional injury. Accordingly,

we affirm the Court of Appeals’ reversal of the compensatory and punitive damage awards based on

Ms. Sparkman’s NIED claim. In addition, we conclude that the punitive damages awarded by the

trial court were adequately supported by the evidence and were not excessive. Therefore, we reverse

the Court of Appeals’ decision to overturn the punitive damage award related to the plaintiffs’

wrongful death claim. Finally, we hold that the trial court erred by recognizing the plaintiffs’ second

failure to warn claim but conclude that the error did not more probably than not affect the judgment

or prejudice the judicial process. Costs of this appeal are taxed equally to the appellee,

DaimlerChrysler Corporation, and the appellants, Jeremy Flax and Rachel Sparkman, and their

sureties for which execution may issue if necessary.

___________________________________

JANICE M. HOLDER, JUSTICE

-22-