# Arlanxeo Canada Inc. v. Kaydon Ring & Seal, Inc.

> District Court, M.D. Pennsylvania · March 31, 2025

URL: https://www.frixlaw.com/law-library/cases/10835986

## Case

- **Court:** District Court, M.D. Pennsylvania
- **Decided:** March 31, 2025
- **Opinion:** 100trialcourt
- **Cited by:** 0 later opinions in the Frix Law Library

## Citator (automated)

- No negative treatment found by the automated citator. That is not the same as a confirmation that the case is good law; read the citing cases.
- Full citator and citing cases: https://www.frixlaw.com/law-library/cases/10835986

## How later opinions describe it (automated extraction)

- finding that a rebuttal report is permissible “if it contains merely an elaboration of and [is] consistent with an opinion/issue previously addressed in the expert report”

## Opinion text

IN THE UNITED STATES DISTRICT COURT
FOR THE MIDDLE DISTRICT OF PENNSYLVANIA

ARLANXEO CANADA, INC., :
Plaintiff : No. 1:21-cv-01843
:
v. : (Judge Kane)
:
KAYDON RING & SEAL, INC., :
Defendant :

MEMORANDUM
Before the Court are Defendant Kaydon Ring & Seal, Inc. (“Defendant”)’s fully briefed
Motions to Preclude the Expert Reports, Testimony, and Opinions of Itzhak Green (Doc. No. 43),
Geoff R. Hall (Doc. No. 42), and Bradley D. Wolf (Doc. No. 44) and Plaintiff Arlanxeo Canada,
Inc. (“Plaintiff”)’s fully briefed Motion to Exclude the Testimony and Report of Doctor Richard
W. Klopp (Doc. No. 40). Neither Plaintiff nor Defendant requested a hearing on the motions.
Upon careful consideration of the briefing and exhibits associated with the motion, and the
applicable law, and for the reasons provided herein, the Court will deny Defendant’s Motions to
Preclude the Expert Reports, Testimony, and Opinions of Itzhak Green, Geoff R. Hall, and
Bradley D. Wolf, and will deny Plaintiff’s Motion to Exclude the Testimony and Report of
Doctor Richard W. Klopp.
I. BACKGROUND1
On October 29, 2021, Plaintiff filed a complaint against Defendant asserting claims of
breach of contract (Count I), breach of warranty (Count II), and negligence (Count III) arising
out of the following facts. Plaintiff runs a butyl rubber production facility in Sarnia, Ontario,
Canada (“Sarnia Facility”). (Doc. No. 1 ¶ 6.) To produce the butyl rubber, the Sarnia facility

1 The following factual allegations are taken from Plaintiff’s Complaint. (Doc. No. 1.)
utilizes two (2) refrigeration compressors, known as the C2 Compressor and C3 Compressor
(collectively “Compressors”). (Id. ¶ 8.) The Compressors are comprised of “vital components”
called mechanical seals (“Seals”). (Id. ¶ 9.) If the Seals fail, then the Compressors fail, and if
the Compressors fail, then the Sarnia facility’s rubber production is “greatly diminished.” (Id. ¶¶

11, 13.) Defendant originally designed and manufactured the eleven (11) Seals utilized by
Plaintiff (four (4) in use and seven (7) in reserve). (Id. ¶¶ 14, 16, 17.) Plaintiff contracted with
Defendant to repair and refurbish all Seals, and those repairs occurred in 2015 and 2016. (Id.)
In 2019, Plaintiff scheduled a major overhaul for the C2 Compressor, a minor overhaul for the
C3 Compressor, and an emergency refurbishment of the Seals. (Id. ¶¶ 20, 25–26.) The
overhauls took place from about September 2019 to about October 2019. (Id. ¶¶ 27, 30–31, 45.)
Both Compressors failed after their respective overhauls. (Id. ¶¶ 30–31, 45.) Plaintiff inspected
the Compressors and found Seals had failed in both. (Id. ¶¶ 32, 46.) A cascade of compressor
failures followed between October 2019 and May 21, 2021. (Id. ¶¶ 35, 37, 48, 41–42, 59, 64, 68,
70.) The C2 Compressor failed eight (8) times and the C3 Compressor failed two (2) times.

(Id.)
Plaintiff noted that the Seals caused each of the compressor failures and notified
Defendant. (Id. ¶¶ 32–33, 36, 38, 41–42, 53–55, 59, 61, 64–65, 66, 68.) After the C2
Compressor’s fourth failure, Plaintiff sent it to a service center in Houston, Texas for a root cause
analysis, which Defendant participated in. (Id. ¶¶ 49, 51, 53.) Defendant’s personnel uncovered
Seal defects and repaired the Seals at its Pennsylvania manufacturing facility before sending
them back to Houston for installation. (Id. ¶¶ 53–55.) After the seventh failure, Plaintiff began a
transition to a new seal supplier, Flowserve Corporation (“Flowserve”). (Id. ¶ 69.) After the
eighth failure, Plaintiff replaced all remaining Seals from Defendant with Seals designed and
manufactured by Flowserve. (Id. ¶¶ 70–71.) Plaintiff’s inspection of the Defendant’s Seals
“indicate that the bushing seal is unbalance[d] as designed, which over time results [in] surface
fretting causing the bushing seal to lock-up, stall, and fail.” (Id. ¶ 18.) Further, Plaintiff’s
inspection also revealed that “the design of the Seals are defective in that they lead to waviness,

taper, coning, and wear of the mechanical face seal which also results in failure.” (Id.)
Defendant filed an answer to the complaint on January 22, 2022. (Doc. No. 6.) The
Court conducted a case management conference and set a close of fact discovery date of
September 30, 2022. (Doc. No. 12.) However, the parties entered into multiple stipulations to
extend the close of fact discovery date (Doc. Nos. 14, 21, 23, 27, 29, 32), before ultimately
stipulating to the close of fact discovery date of July 31, 2023 (Doc. No. 32). The Court
conducted a post-fact discovery status conference on August 17, 2023, and set a close of expert
discovery date of March 1, 2024. (Doc. No. 35.) On February 28, 2024, the Court permitted the
parties to conduct the depositions of Dr. Itzhak Green (“Dr. Green”) on March 5, 2024, and Dr.
Richard Klopp (“Dr. Klopp”) on March 25, 2024, as exceptions to the March 1, 2024 close of

expert discovery date pursuant to a stipulation filed by the parties. (Doc. Nos. 36–37.)
Subsequently, the Court conducted a post-expert discovery conference on April 11, 2024, and set
a Daubert motion deadline of May 23, 2024. (Doc. No. 39.)
On May 23, 2024, Plaintiff filed a Motion to Exclude the Testimony and Report of Dr.
Klopp (Doc. No. 40) and Defendant filed Motions to Preclude the Reports, Testimony, and
Opinions of Geoff R. Hall (“Mr. Hall”) (Doc. No. 42), Dr. Green (Doc. No. 43), and Bradley D.
Wolf (“Mr. Wolf”) (Doc. No. 44). Both parties filed their respective briefs in support of their
motions on June 6, 2024. (Doc. Nos. 45, 46, 47, 48.) Plaintiff filed briefs in opposition to
Defendant’s motions on June 20, 2024, (Doc. No. 50, 51, 52), and Defendant filed a brief in
opposition to Plaintiff’s motion on the same date (Doc. No. 49). On July 3, 2024, Plaintiff filed a
reply brief in support of its Motion to Exclude the Testimony and Report of Dr. Klopp (Doc. No.
53), and on July 5, 2024, Defendant filed reply briefs in support of its Motions to Preclude the
Reports, Testimony, and Opinions of Mr. Hall, Dr. Green, and Mr. Wolf (Doc. No. 54, 55, 56).

Having been fully briefed, Plaintiff’s Motion to Exclude the Testimony and Report of Dr. Klopp
and Defendant’s Motions to Preclude the Reports, Testimony, and Opinions of Mr. Hall, Dr.
Green, and Mr. Wolf are ripe for disposition.
II. LEGAL STANDARD
Federal Rule of Evidence 702 governs the admissibility of expert testimony. See Fed. R.
Evid. 702. Rule 702 states:
A witness qualified as an expert by knowledge, skill, experience, training, or
education, may testify in the form of an opinion or otherwise, if the proponent
demonstrates to the court that it is more likely than not: (a) the expert’s scientific,
technical, or other specialized knowledge will help the trier of fact to understand
the evidence or to determine a fact in issue; (b) the testimony is based upon
sufficient facts or data, (c) the testimony is the product of reliable principles and
methods, and (d) the expert’s opinion reflects a reliable application of the principles
and methods to the facts of the case.

See id.
As the United States Court of Appeals for the Third Circuit (“Third Circuit”) has
explained, “Rule 702 embodies a trilogy of restrictions on expert testimony: qualifications,
reliability and fit.” See Schneider v. Fried, 320 F.3d 396, 404 (3d Cir. 2003). The rule imposes
an obligation on district court judges to act as “gatekeepers” to ensure that an expert witness’s
testimony meets those three threshold requirements before consideration by a jury. See Kumho
Tire Co. v. Carmichael, 526 U.S. 137, 147 (1999); Daubert v. Merrell Dow Pharm., Inc., 509
U.S. 579, 597 (1993). In fulfilling its obligation as a gatekeeper, a court exercises discretion
when deciding whether to admit or deny expert testimony. See Gen. Elec. Co. v. Joiner, 522 U.S.
136, 146–47 (1997).
When considering the qualification requirement, a court must discern whether a
purported expert has specialized knowledge in a given field. See Pineda v. Ford Motor Co., 520

F.3d 237, 244 (3d Cir. 2008). No particular background or credentials are necessary to establish
the requisite specialized knowledge, as “a broad range of knowledge, skills, and training qualify
an expert.” See In re Paoli R.R. Yard PCB Litig., 35 F.3d 717, 741 (3d Cir. 1994); accord
Waldorf v. Shuta, 142 F.3d 601, 627 (3d Cir. 1998) (noting that a proposed expert witness’s
generalized knowledge or practical experience may be sufficient to qualify him as an expert).
Although the Third Circuit has instructed that a court must “eschew [] imposing overly vigorous
requirements of expertise,” the determination of whether an expert is qualified to testify about a
particular topic is not one that has been reduced to a mere formality, as the court’s assessment of
a proposed expert’s qualifications is predominantly a fact-specific endeavor that is governed by
the unique circumstances in each case. See Voilas v. Gen. Motors Corp., 73 F. Supp. 2d 452, 456

(D.N.J. 1999) (quoting United States v. Velasquez, 64 F.3d 844, 849 (3d Cir. 1995)).
As for the reliability requirement, the United States Supreme Court has held that the
gatekeeping function requires the trial court to “make certain that an expert, whether basing
testimony upon professional studies or personal experience, employs in the courtroom the same
level of intellectual rigor that characterizes the practice of an expert in the relevant field.” See
Kumho Tire, 526 U.S. at 152. To meet this requirement, “a litigant has to make more than a
prima facie showing that his expert’s methodology is reliable,” but the “evidentiary requirement
of reliability is lower than the merits standard of correctness.” See Pineda, 520 F.3d at 244
(quoting In re Paoli, 35 F.3d at 744). The expert’s opinion “must be based on the methods and
procedures rather than on subjective belief or unsupported speculation.” See In re TMI Litig.,
193 F.3d 613, 664 (3d Cir. 1999). “The focus is not upon the expert’s conclusions, but rather
upon his methodology; the issue is whether the evidence should be excluded because the flaw is
large enough that the expert lacks good grounds for his or her conclusions.” Burke v. TransAm

Trucking, Inc., 617 F. Supp. 2d 327, 331 (M.D. Pa. 2009) (citing In re Paoli, 35 F.3d at 746).
When evaluating the reliability of a witness’s methodology, a court is guided by several familiar
factors drawn from Daubert:
(1) whether a method consists of a testable hypothesis; (2) whether the method has
been subject to a peer review; (3) the known or potential rate of error; (4) the
existence and maintenance of standards controlling the technique’s operation; (5)
whether the method is generally accepted; (6) the relationship of the technique to
methods which have been established to be reliable; (7) the qualifications of the
expert witness testifying based on the methodology; and (8) the non-judicial uses
to which the method has been put.

See In re Paoli, 35 F.3d at 742 n.8. These factors “may or may not be pertinent in assessing
reliability, depending on the nature of the issue, the expert’s particular expertise, and the subject
of his testimony.” See Kumho Tire, 526 U.S. at 150. Accordingly, the Rule 702 inquiry is a
flexible one, and the court should also take into account any other relevant factors. See Calhoun
v. Yamaha Motor Corp., 350 F.3d 316, 321 (3d Cir. 2003).
Under the third requirement—fit—“the expert’s testimony must be relevant for the
purposes of the case and must assist the trier of fact.” See Schneider, 320 F.3d at 404. “Rule
702’s helpfulness standard requires a valid scientific connection to the pertinent inquiry as a
precondition to admissibility.” Daubert, 509 U.S. at 591–92. Indeed, an expert who renders an
opinion based on factual assumptions not present in the case or opines on a matter that does not
relate to a disputed issue is not relevant and, thus, will not assist the trier of fact, as required by
Rule 702. See id. For example:
The study of the phases of the moon … may provide valid scientific “knowledge”
about whether a certain night was dark, and if darkness is a fact in issue, the
knowledge will assist the trier of fact. However (absent creditable grounds
supporting such a link), evidence that the moon was full on a certain night will not
assist the trier of fact in determining whether an individual was unusually likely to
have behaved irrationally on that night.

See id. Like the typical relevance inquiry, “the standard for analyzing the fit of an expert’s
analysis to the case at hand is ‘not that high.’” See United States v. Ford, 481 F.3d 215, 219 n.6
(3d Cir. 2007) (quoting In re Paoli, 35 F.3d at 745). However, expert testimony can be powerful
and misleading because of the difficulty in evaluating it, and the Third Circuit has cautioned that
“district courts should tread carefully when evaluating proffered expert testimony, paying special
attention to the relevance prong of Daubert.” See id. at 219 n.6.
III. DISCUSSION
A. Defendant’s Motion to Preclude the Expert Report, Testimony, and Opinion
of Dr. Green

1. The Proposed Expert Report and Testimony of Dr. Green

Plaintiff argues that Defendant breached its contract with Plaintiff, breached warranties,
and acted negligently because Defendant “failed to timely perform the repairs and refurbishment
within the time period provided by the contracts,” “repetitively failing to design, refurbish[,] and
repair the Seals,” and negligently designing and failing to properly investigate and remedy
design defects in the refurbishment process. (Doc. No. 1 ¶¶ 76–77, 81, 85.) To prove those
claims, Plaintiff tenders Dr. Green as an expert to opine on the design defects of the Seals and the
cause of the seal failures, and the standard of care required and expected of seal manufacturers
(which relates to Plaintiff’s claim of negligence). (Doc. No. 52 at 5.) As to the first issue, Dr.
Green’s Report concludes as follows:
[Defendant’s] bushing seal failed recurrently in the C2 and/or C3 Compressors
(failed a total of 10 times between September 2019 and May 2021)[.]
Specifically, the bushing seal in the original [Defendant] design has inherent
weaknesses: (1) it is not force-balanced hydraulically[;] (2) it relies on or assumes
perfect (i.e., “smooth” or “frictionless”) surface conditions between the bushing
face and the housing[;] (3) the carbon ring is a hard and brittle material that is
unforgiving when the bushing and the shoulder rings come into contact (or
impact)[;] (4) such contact wears the shoulder and carbon surfaces, while wear
debris escalate wear and degrades the surfaces further[;] (5) the rubbing contact
(impact) is known to instigate vibrations[;] and (6) the chrome plated shoulder is
inferior (in many aspects) to a tungsten carbides coated shoulder. Hence, the
[Defendant] bushing seal has had limited to no ability to accommodate commonly
occurring shaft excursions. That inability led to rubbing contact at the bushing seal
surfaces that caused severe wear of the entire seal assembly perpetually, and
ultimately caused the seals failures [sic].

Machine vibration is common and normal in any practical rotating machinery as
they are in the C2 and C3 Compressors. Sporadic vibrations also occurred
historically prior to 2019 (i.e., between 2005-2019) according to Siemens’ root
cause analysis, and such vibrations have not caused seal failures during that period
of time (2005-2019). Indeed, third parties involved in the seal investigation failure
note that the vibrations briefly peaked during startup but immediately went away
— the excitations happen only at speed changes and not during steady-state
operation. However, the seal failures were not caused by vibration-related events.

(Doc. No. 43-5 ¶ 134(a)–(c) (cleaned up).)
As to the second issue, Dr. Green’s Report concludes the following:
As discussed above, the Siemens [root cause analysis] made definitive
recommendations to replace in the bushing seal the chrome plating with a tungsten
carbide coating, and to replace the carbon-graphite with [b]abbitt. Those
recommendations are based on current, known, and proven engineering practices.
Even though those clear and specific requests had been forwarded to [Defendant],
[Defendant] repeatedly declined the requests. [Defendant] has never offered
effective solutions to the repeated seal failure problems.

It is field proven (i.e., in the operation of the actual C2 Compressor) that the
recommendations as requested by Siemens, AST, and ARLANXEO — and as
implemented by Flowserve — had been completely effective in solving the
repeated seal failures. Flowserve refurbished a failed Kaydon seal abiding by the
said recommendations. That seal had been installed in the same machine (i.e., the
same C2 compressor, with all its accessories, bearings, gearbox, coupling, etc.) in
which [Defendant] seals had previously failed eight times. However, the Flowserve
refurbished seal had functioned without a single seal failure since its installation.
It was mainly the [Defendant] bushing seal that had been replaced with the
Flowserve bushing seal. The Flowserve refurbished seal included a Babbitted
bushing (instead of [Defendant’s] carbon-graphite bushing), and it had a tungsten
carbide coating on the shoulder ring (instead of [Defendant’s] chrome plated
shoulder). Additional minor changes to the bushing geometry and the inclusion of
an O-ring seal have further helped mitigating the seal failure problems. Had
[Defendant] made those changes, this [a]ction likely would not have commenced.
That is a compelling conclusion that just the revision of the [Defendant] bushing
seal has made all other arguments (regarding vibrations, pressure variations,
gearbox, coupling, start-up transients, etc.) irrelevant.

Closing observation: [t]here was a machine (the C2 Compressor) with all of its
supporting accessories (bearings, gear box, coupling, driving motor) that operated
under certain operating conditions, while complying with all of requirements of the
compressors manufacturer limits. When [Defendant’s] [S]eals, as refurbished by
[Defendant], were installed into the machine, those seals failed eight times since
the late 2019 to the mid-2021. When a failed [Defendant] seal had been refurbished
by Flowserve[] and installed in 2021 in the very same machine (with all its identical
accessories, and operating conditions), the seal and the entire machine never failed.
That machine (being a “nondiscriminatory object”) proves that the [Defendant’s]
seals as refurbished by [Defendant] were at fault for the entire Compressor trip and
shut down, and with it, adversely impacting the plant’s rubber production. In my
professional opinion, and for the reasons set out above, [Defendant] breached the
standard of care required and expected of a reasonable
manufacturer, and the seal failures would not have occurred but for that breach.

(Id. ¶ 134(d)–(f) (cleaned up).)
Defendant argues that the testimony and report of Dr. Green should be excluded because
Dr. Green’s methods utilized in his report are unreliable, and his opinions, which focus upon
Defendant’s Seals and the standard of care required and expected of a reasonable manufacturer,
are an improper fit for the issues in this case. (Doc. No. 46 at 4, 14, 19.) Specifically, Defendant
asserts that Dr. Green can neither reliably opine on the root cause of the ten compressor failures
nor opine on the standard of care required and expected of a reasonable manufacturer because he
did not conduct a root cause analysis and has no training, formal education, or experience to
qualify him as an expert on the standard of care expected or required of a reasonable
manufacturer. (Id. at 5–6.) Defendant also argues that Dr. Green’s method of a root cause
analysis that involves conducting surface measurements and looking at machine parts,
deformation, wear tracks, and failed components is not a root cause analysis and does not satisfy
the Daubert factors. (Id. at 17.) Specifically, Defendant argues that: (1) Dr. Green’s method does
not consist of a testable hypothesis; (2) Dr. Green’s method is not subject to peer review; (3)
there is no known potential rate of error because Dr. Green’s method is not a method and merely
focuses on seal design; (4) there are no standards that control Dr. Green’s methodology; (5) Dr.

Green’s methodology is idiosyncratic and is not generally accepted; (6) Dr. Green chose not to
apply a generally accepted and reliable method, which is not expertise; (7) Dr. Green is not
qualified to testify on a root cause analysis because it is not his area of expertise; and (8) there
are no other cases of Dr. Green’s method being applied by anyone else or outside a judicial
setting. (Id. at 18.) Defendant further argues that Dr. Green’s opinions do not fit this case
because his opinion that Defendant “breached the standard of care required and expected of a
reasonable manufacturer” is unsupported by either his own expertise (which is not in standards
of care expected or required of a reasonable manufacturer) nor his experience. (Id. at 19.)
In response, Plaintiff asserts that Dr. Green should not be excluded because Dr. Green
completed a root cause analysis on the Compressors, his method is reliable, his qualifications

support his opinion on the root cause of the seal failures and the standard of care required of a
seal manufacturer, and his opinions fit the case. (Doc. No. 52 at 12, 14, 20.) Plaintiff argues that
Dr. Green completed a root cause analysis that involved interviewing Plaintiff’s representatives,
reviewing all the evidence available to date, inspecting the Compressors personally, and
verifying and reviewing the root cause analyses of third parties. (Id. at 13.) In support of its
argument that Dr. Green’s method is reliable, Plaintiff asserts that Dr. Green followed the
scientific method, evaluated all potential causes of the Defendant’s seal failures, performed his
own root cause analysis, and evaluated the various opinions of third parties to conclude “to a
reasonable degree of scientific certainty that the [Defendant’s] [] Seals had inherent weaknesses
in six technical aspects.” (Id. at 16.) Plaintiff further argues that, contrary to Defendant’s
assertion, Dr. Green is qualified based on his internationally recognized expertise on seal design,
machinery, rotor dynamics,2 and tribology,3 which he has translated into over one hundred and
fifty (150) papers and reports. (Id. at 18.) With regard to fit, Plaintiff further argues that Dr.

Green’s opinions fit the instant case because the case concerns a breach of contract, breach of
warranty, and negligence arising out of seal failures. (Id. at 21.) Finally, Plaintiff asserts that Dr.
Green should be allowed to opine on the standard of care of a reasonable seal manufacturer
because Dr. Green has worked with manufacturers to provide input on mechanical seal
production, design, and/or servicing. The Court first reviews Dr. Green’s qualifications before
addressing the reliability of his methodology and the “fit” of his opinions to the facts of this case.
2. Qualifications
Defendant argues that Dr. Green is not qualified to offer expert testimony about the root
cause of the compressor failures and a manufacturer’s standard of care because he has no
experience, training, or academic background in the topic of root cause analyses or the standards

of care of reasonable manufacturers. (Doc. No. 46 at 18–19.) Although Defendant’s argument
regarding Dr. Green’s lack of qualification is mentioned in connection with its reliability

2 Rotor dynamics is the study of “the dynamic behavior of rotating blades in high-speed and
multi-load excitation environments, considering factors such as centrifugal stiffening, spin
softening, and Coriolis force.” See ScienceDirect, Rotor Dynamics,
https://www.sciencedirect.com/topics/physics-and-astronomy/rotor-dynamics#definition (last
visited Feb. 8, 2025).

3 Tribology is the study of “interacting surfaces in relative motion and with associated matters
(as friction, wear, lubrication, and the design of bearings).” See Tribology, Oxford English
Dictionary, https://www.oed.com/dictionary/tribology_n?tab=meaning_and_use#17803703 (last
visited Feb. 8, 2025).
argument,4 the Court construes the argument as a broader attack on Dr. Green’s qualifications to
serve as an expert. (Doc. No. 46 at 18.) Therefore, the Court will briefly review Dr. Green’s
qualification to serve as an expert in this case pursuant to Rule 702.
Dr. Green’s Report states that he received his Bachelor of Science, Master of Science,

and Doctor of Philosophy degrees from the Technion-Israel Institute of Technology in 1977,
1980, and 1984, respectively. (Doc. No. 43-5 ¶ 10.) Dr. Green has over forty-four (44) years of
experience in research and development of sealing and bearing technologies, and in the general
fields of rotor dynamics and tribology. (Id. ¶ 11.) In addition to his doctoral thesis titled
“Dynamics of Mechanical Seals” and his master’s thesis “Dynamic Analysis of a Flexibly
Mounted Gas Thrust Bearing,” Dr. Green has authored and co-authored one hundred and fifty
(150) papers and reports in tribology and design, rotor dynamics, integrated diagnostics,5
dynamic analysis of mechanical face seals, mechanics of viscoelastic dampers,6 among other
topics. (Id. ¶¶ 11–13.) Additionally, Dr. Green has published over seventy (70) journal-refereed

4 Defendant challenges Dr. Green’s qualifications with regard to his opinions as to the root cause
of the compressor failure as an indication of the unreliability of his expert testimony under factor
seven of the Paoli factors. (Doc. No. 46 at 18.)

5 Integrated diagnostics is defined as a structured process by which one can “maximize[] the
effectiveness of diagnostics by integrating pertinent elements, such as testability, automatic and
manual testing, training, maintenance aiding, and technical information as a means for providing
a cost effective capability to unambiguously detect and isolate all faults known or expected in
items and to satisfy system mission requirements.” See Defense Acquisition University,
Integrated Diagnostics, Glossary, https://www.dau.edu/glossary/integrated-diagnostics (last
visited Feb. 11, 2025).

6 A viscoelastic damper is a type of passive control device used to “dissipate strain energy in the
form of heat when subjected to [] deformation [from the application of a repeated load] in
dynamic load conditions.” Melina Bosco, Andrea Floridia & Pier Paolo Rossi, Proposal of a
Design Procedure for Steel Frames with Viscoelastic Dampers, 2024 Applied Sci. 14, 6937, 1,
https://www.mdpi.com/2076-3417/14/16/6937.
papers concerning seals and sealing technology. (Id. ¶ 14.) In 1998, Dr. Green was awarded the
Best Sealing Technology Paper by the Society of Tribologists and Lubrication Engineers
(“STLE”). (Id. ¶ 17.)
Dr. Green has received the most prestigious awards of two divisions of the American

Society of Mechanical Engineers (“ASME”): (1) the Machine Design Award “for outstanding
achievements and dedication to excellence in design education, innovation, service and research”
in 2006; and (2) the Mayo D. Hersey Award for “distinguished and continued contributions over
a substantial time period to the advancement of the science and engineering of tribology.” (Id. ¶
18.) Moreover, Dr. Green has served in numerous positions in technical industry societies such
as: Technical Associate Editor for the ASME Transactions Journal of Tribology; Associate Editor
for STLE, Tribology Transactions; Director of the STLE Board; and Chair of the Executive
Committee of the ASME Tribology Division. Dr. Green currently serves as an Advisory Board
Member of “‘Machines,’ an MDPI open access journal.”7 (Id. ¶ 19.)
As for work experience, Dr. Green has been a professor and course administrator at the

George W. Woodruff School of Mechanical Engineering at the Georgia Institute of Technology
from 1988 to present. (Id. ¶ 20.)8 Dr. Green taught two graduate classes on a yearly basis on
fluid film lubrication and rotor dynamics, worked as an instructor and course administrator for a
continuing education course on fluid sealing technology from 1988 to 2009, and from 1988 to

7 MDPI is the name of an open-access publishing website based in Basel, Switzerland. See
Overview, MDPI, https://www.mdpi.com/about (last visited Feb. 11, 2025).

8 Although Dr. Green’s statement of his qualifications does not include information about
whether he is still employed at the Georgia Institute of Technology, a review of the university’s
website reveals that Dr. Green is still a faculty member. Itzhak Green, Ga. Inst. Tech.: George W.
Woodruff Sch. of Mechanical Engineering Fac. & Staff,
https://www.me.gatech.edu/faculty/green (last visited Feb. 11, 2025).
2001 taught “all of the mechanics and design subjects for the Professional Engineering Refresher
Course for the PE Exam.” (Id. ¶¶ 20–21.) Additionally, since 1985, Dr. Green has consulted for
at least twelve (12) different companies including: Scientific Atlanta; Inpro Seal, Inc.; Georgia
Pacific Pump Co.; Bard Urological Division; Stone Container; Robins, Kaplan & Ciresi;

Schlumberger, Pratt & Whitney; General Dynamics; Quest Air; Eaton; and Intel Corp. (Doc. No.
52-7 at 27–28.) For those companies, Dr. Green consulted on seal design, failure diagnosis, and
trade studies on mechanical seals, among other topics. (Id.) Dr. Green has received a patent for
his design of a “Secondary Gas/Liquid Mechanical Seal Assembly” (id.) and has also developed
computer codes for mechanical seals that were acquired by research labs and by companies that
design and manufacture mechanical seals and turbomachinery (Doc. No. 43-5 ¶ 15).
Upon consideration of all of the above, the Court concludes preliminarily that Dr. Green
appears qualified to offer testimony as an expert on the subject of the cause of the Seal failures
and the standard of care required and expected of manufacturers of Seals. Accordingly, the
Court turns to an assessment of the reliability and fit of the two opinions proffered by him in this

case.
3. Dr. Green’s Opinion on the Cause of the Seal Failures
Plaintiff proffers Dr. Green to opine on the cause of the seal failures. (Doc. No. 52 at 5.)
As explained supra, Dr. Green determined that the Seals failed due to defects in the design of the
Seals which led to, among other things, “rubbing contact at the bushing seal surfaces that cause
severe wear of the entire seal assembly perpetually.” (Doc. No. 43-5 ¶ 134(b).) The Court
reviews the reliability of Dr. Green’s opinion on the cause of the seal failures before turning to
the “fit” of his opinion on the cause of the seal failures.
a. Reliability
As set forth more fully supra, the reliability inquiry focuses on an expert’s methodology
and whether he or she has good grounds for the opinion offered. See In re Paoli, 35 F.3d at 746.
In re Paoli sets forth numerous factors to guide the Court in evaluating the reliability of a

witness’s methodology as follows:
(1) whether a method consists of a testable hypothesis; (2) whether the method has
been subject to peer review; (3) the known or potential rate of error; (4) the
existence and maintenance of standards controlling the technique’s operation; (5)
whether the method is generally accepted; (6) the relationship of the technique to
methods which have been established to be reliable; (7) the qualifications of the
expert witness testifying based on the methodology; and (8) the non-judicial uses
to which the method has been put.

See id. at 742 n.8. However, those factors “are neither exhaustive nor applicable in every case.”
See Pineda, 520 F.3d at 248 (citing Kannankeril v. Terminex Int’l, Inc., 128 F.3d 802, 806–07 (3d
Cir. 1997) and Kumho Tire, 526 U.S. at 151).
In Defendant’s brief in support of its motion, Defendant argues that Dr. Green’s opinion
on the cause of the seal failures is not reliable because “[Dr. Green] concedes that he did not
conduct a root cause analysis on the failures…for each or any seal failure.” (Doc. No. 46 at 14–
15.) Specifically, Defendant asserts that Dr. Green failed to use a generally accepted root cause
analysis such as “the Six Sigma root cause analysis method, a Fishbone diagram, Pareto Charts,
Fault Tree Analysis, as well as the 8D Process.” (Id. at 16.) Plaintiff counters that Dr. Green
conducted his own root cause analysis that involved looking at the design of the seals, the reports
from the root cause analyses of Siemens and other companies, analyzing the force balance on the
mechanical seal, and applying the concepts to the force balance on the bushing seal. (Doc. No.
52 at 13.)
Upon careful review of Dr. Green’s Report, the briefs of the parties, and the relevant
authorities, the Court concludes that Dr. Green’s opinion that inherent weaknesses in the design
of Defendant’s bushing seal caused the bushing seal to fail and the Compressors to fail is based
upon reliable methodology. Dr. Green derived his opinion on the bushing seal’s faulty design

from the following sources: (1) personal inspection of four Seals (all designed by Defendant but
two of the four were refurbished by Flowserve Corporation); (2) personal inspection of the
Compressors after the eighth seal failure of the C2 Compressor and the second seal failure of the
C3 Compressor; (3) personal interviews with Plaintiff’s representatives; (4) the Siemens Root
Cause Analysis Report; (5) the IMR Test Labs Report; (6) the AST Turbo Report; and (7) the
Kaydon Report. (Doc. Nos. 52-1 ¶¶ 31–36, 134; 52-8 at 17.) Therefore, the Court agrees with
Plaintiff that Dr. Green’s Report presents a methodology that is beyond ipse dixit because Dr.
Green reviewed the four reports that were written before his hiring, personally inspected the
Seals and Compressors, interviewed Plaintiff’s personnel, and then combined that information
with his knowledge and expertise on seal designs to come to his conclusion that the cause of the

failures was related to the bushing seal design. See David v. Black & Decker (US) Inc., 629 F.
Supp. 2d 511, 515–16 (W.D. Pa. 2009) (concluding that a mechanical engineer’s report and
testimony satisfied the reliability prong of Rule 702 because the engineer’s opinion was based on
inspection of the object, testing of a substantially similar object, and using recognized data to
develop opinions on the relevant parts of the object). Accordingly, the Court concludes that Dr.
Green’s Report and opinion regarding the cause of the seal failures satisfies the second prong of
reliability of Rule 702 and turns to the “fit” of the opinion to the issues of this case.
b. Fit
Next, this Court considers whether Dr. Green’s opinion “fits” the case. The fit
requirement is ultimately a question of whether the expert’s opinions are “connected to the
question at issue.” See In re Paoli, 35 F.3d at 745 n.13. Although the standard is “not that high,”

the standard is nonetheless “higher than bare relevance.” See id. at 745.
Defendant argues that Dr. Green’s opinion does not fit the instant case because Dr. Green
analyzed the Seals instead of conducting a full root cause analysis of the Compressors. (Doc.
No. 46 at 18.) Defendant further states that “the issue in this case is not whether [its] [S]eals
could have been designed differently, but whether [its] [S]eals were the root cause of each of the
ten compressor failures.” (Id.) Plaintiff contends that all three claims asserted against Defendant
relate to Defendant’s “failure to appropriately design, refurbish, and repair [its] [] Seals,” and Dr.
Green provides an opinion on the cause of the seal failures. (Doc. No. 52 at 20–21.)
The Court agrees with Plaintiff that Dr. Green’s opinion on the seal failures “fits” this
case. From the beginning, Plaintiff noted that the failure of the Compressors was tied to the

Seals. (Doc. No. 1 ¶¶ 32, 46 (“Upon inspection, [Plaintiff] observed that the C2 Compressor
failed as a result of a failure of a drive-end Seal designed and refurbished by [Defendant]… [The
October 25, 2019] failure [of the C3 Compressor] occurred because the non-drive-end Seal failed
to operate properly.”).) Further, the compressor failures and inquiries into those failures revealed
that the Seals were sustaining damage and were failing. (Id. ¶¶ 18, 38, 42, 48, 54–55, 59, 61,
64–65, 67–68.) Therefore, this case concerns the Seals and the cause of their failures. Returning
to the expert report and testimony of concern in this motion, Dr. Green’s Report and testimony
go directly to the cause of the seal failures. Although Defendant argues that Dr. Green’s Report
and opinions focus on the design of the Seals (Doc. No. 46 at 18–19), the Court finds that the
report and opinions explain that the design of the Seals are the reason why the Seals failed (Doc.
No. 52-1 at 40–41). Accordingly, the Court concludes that Dr. Green’s Report and opinion on
the Seals will assist the trier of fact in determining the issues in the case because they go directly
to the issues at the heart of Plaintiff’s complaint.

3. Dr. Green’s Opinions on the Standard of Care of a Reasonable Seal
Manufacturer

Plaintiff proffers Dr. Green to opine on the standard of care of a reasonable seal
manufacturer. (Doc. No. 52 at 11.) Specifically, as elucidated supra, Dr. Green opined that
Defendant’s refusal to implement the recommendations by Siemens, AST Turbo, and Plaintiff to
redesign the Seals with a babbitted bushing seal and a tungsten carbide coating on the shoulder
ring, in the face of ten seal failures, indicates Defendant’s breach of the standard of care of a
reasonable manufacturer. (Doc. No. 43-5 ¶ 134(d)–(f).)
a. Reliability
Defendant argues that Dr. Green’s opinion on a seal manufacturer’s standard of care
should be precluded because Dr. Green did not cite to what those standards of care are, did not
provide any basis for his standard, and used no methodology against which to measure
Defendant’s conduct. (Doc. No. 46 at 20.) On the other hand, Plaintiff argues that Dr. Green’s
opinion on a seal manufacturer’s standard of care is reliable because Dr. Green’s Report
explained what a reasonable and prudent manufacturer would have done, i.e., made the
recommended changes to the Seals, and his methodology of making the recommended changes
to the Seals was tested by Flowserve. (Doc. No. 52 at 22–23.)
As with the bushing seal design opinion, the Court also finds a sufficient methodology
for Dr. Green’s opinion that Defendant breached the standard of care required by a manufacturer.
Dr. Green relies on the following sources: (1) the Siemens Root Cause Analysis Report, which
recommended replacement of the bushing seal’s chrome plating and carbon-graphite; (2) the
AST Turbo Report; (3) Plaintiff’s recommendation to Defendant to make changes to the seal
design; (4) the refusals by Defendant to fulfil the requested recommendations; and (5) the
personal inspection of the four (4) seals. (Doc. No. 52-1 ¶ 134(d)–(f).) Dr. Green thus derived

his opinion on Defendant’s violation of the standard of care expected of a seal manufacturer from
the combination of the recommendations from Siemens, AST Turbo, and Plaintiff to change the
seal design, his inspection of the Seals himself, and his knowledge of current, known, and proven
engineering practices, and his expertise consulting seal manufacturers. As the Supreme Court in
Kumho Tire Co., Ltd. v. Carmichael held, “[Daubert’s] list of factors was meant to be helpful,
not definitive… those factors do not necessarily apply even in every instance in which the
reliability of scientific testimony is challenged.” See Kumho Tire Co., Ltd., 526 U.S. at 141.
Although Dr. Green’s methodology may not satisfy every Daubert factor, Dr. Green’s opinions as
to standard of care are based on his review of prior reports, personal inspection of the Seals and
Compressors, interviews with relevant parties, Defendant’s statements, and his training,

experience, and education, all of which are “‘an objective anchor for his conclusions’ beyond
mere training and experience.” See Pease v. Lycoming Engines, No. 10-cv-00843, 2011 WL
6339833, *9 (M.D. Pa. Dec. 19, 2011) (quoting Booth v. Black & Decker, Inc., 166 F. Supp. 2d
215, 218–22 (E.D. Pa. 2001)) (finding an expert’s report and opinions on the cause of a plane
crash, manufacturing, and standards of care reliable where such opinions are anchored in facts
beyond an expert’s training and experience). Accordingly, the Court concludes that Dr. Green’s
opinion on the standard of care expected of a reasonable manufacturer is reliable and turns to an
assessment of whether his opinion “fits” the issues in this case.
b. Fit
Defendant asserts that Dr. Green’s opinion on the standard of care does not fit this case
because this is a case that involves breach of contract, breach of warranty, and negligence, which
do not require a showing of a breach of a standard of care. (Id. at 20 n.3.) Plaintiff responds that

because this case involves the claims of breach of contract, breach of warranty, and negligence
arising out of Defendant’s failure to appropriately design, refurbish, and repair its Seals, Dr.
Green’s opinion on the standard of care fits this case. See (Doc. No. 52 at 20–21).
Upon careful review of Dr. Green’s Report, the briefs of the parties, and the relevant
authority, the Court concludes that Dr. Green’s opinion on the standard of care “fits” the case.
The Court is unpersuaded by Defendant’s assertion that proof of breach of a standard of care is
not relevant to Plaintiff’s claim of negligence. Defendant’s argument that Plaintiff’s negligence
claim “is based upon the allegation that [its] [S]eal[s] w[ere] defective” (Doc. No. 46 at 20 n.3),
ignores Plaintiff’s second basis for its negligence claim: “[Defendant’s] negligent and defective
design of the Seals, in combination with its failure to properly investigate and remedy such

defects during the refurbishment process, caused the C2 and C3 Compressors to fail on
numerous occasions” (Doc. No. 1 ¶ 85 (emphasis added)). In order to prove negligence under
Pennsylvania law, Michigan law, or Ontario law, Plaintiff must show that Defendant owed a duty
of care.9 See Grove v. Port Auth. of Allegheny Cty., 218 A.3d 877, 888–89 (Pa. 2019) (listing
the elements of negligence as duty, breach, causation, and actual damages); Case v. Consumer

9 There remains an outstanding conflict of laws question in this case as to whether Pennsylvania
law, Michigan law, or Ontario law governs the claims in this case. (Doc. Nos. 1 ¶ 21; 45 at 5
n.1.) Although Plaintiff placed the Court on notice of the choice of law issue, see (id.), the
parties have not yet presented the issue to the Court for determination. Therefore, out of an
abundance of caution, the Court considers whether Dr. Green’s opinion on the standard of care
“fits” the claim of negligence under Pennsylvania law, Michigan law, or Ontario law.
Powers Co., 463 Mich. 1, 6 (2000) (listing the elements of a prima facie case of negligence as
duty, breach, causation, and damages); 1688782 Ontario Inc. v. Maple Leaf Foods Inc., et al.,
[2020] 3 S.C.R. 504, 506 (Ca.) (listing the elements of negligence in Ontario as: (1) defendant
owed plaintiff a duty; (2) that defendant’s conduct breached the standard of care; (3) plaintiff

sustained damage; (4) plaintiff’s damage was caused, in fact and in law, by the defendant’s
breach). Thus, no matter what law applies to this case, a trier of fact must take into account the
standard of care required and expected of a reasonable manufacturer to determine if Defendant
breached that duty. Accordingly, the Court also concludes that Dr. Green’s opinion as to
Defendant’s breach of the standard of care required and expected of a manufacturer will assist
the trier of fact in determining the issues in this case because it goes directly to the issues at the
heart of Plaintiff’s claim of negligence. Therefore, the Court will deny Defendant’s Motion to
Exclude the Expert Report, Testimony, and Opinion of Dr. Green. The Court turns to Plaintiff’s
Motion to Exclude the Testimony and Report of Dr. Klopp.
B. Plaintiff’s Motion to Exclude the Testimony and Report of Dr. Klopp

1. The Proposed Expert Report and Testimony of Dr. Klopp

Defendant tenders Dr. Klopp as an expert to rebut Dr. Green’s report and opinions that
defects in the Seals’ design caused their failures (the first issue in this case). (Doc. No. 49 at 5–6
(describing Dr. Klopp as Defendant’s rebuttal witness charged to assess the sufficiency of Dr.
Green’s root cause determination).) The report proffered by Dr. Klopp (“Dr. Klopp’s Report”)
concludes as follows:
The seal failures are a symptom and not a cause of the compressor failures. The
seals in the compressor operated without incident for nearly 40 years until the
overhaul of the subject C2 compressor in 2019. To a reasonable degree of
engineering certainty, something about the major overhaul triggered the subsequent
seal failures.
Due to a lack of evidence, no one can identify the specific change or changes in the
compressor during the overhaul leading to the subsequent seal failures, and for that
reason alone, there is insufficient evidence to conclude the seals are defective to a
reasonable degree of engineering certainty.

Given the repeated issues with other components, it is likely that Arlanxeo did not
properly operate, maintain, or repair the subject compressors.

Dr. Green failed to do a proper failure analysis and omitted the contribution of
failures of other components within the compressor, including bearing wipes,
housing warpage requiring re-machining, rotor damage requiring weld repairs,
diaphragm damage requiring replacement, and contaminated oil systems.

Dr. Green appears to have sufficient knowledge to help others understand the issues,
but his opinions are not based on sufficient facts because he has omitted key facts,
his opinions are not the product of the application of reliable principles and
methods, namely, the scientific method, and his opinions do not reflect a reliable
application of the scientific method because of the failure to apply it to key facts,
including those that contradict his opinions.

(Doc. No. 41 at 9.)
Plaintiff argues that the testimony and report of Dr. Klopp should be excluded because he
is not qualified, his opinion lacks any reliable methodology, and it does not “fit” the issue in this
case. (Doc. No. 48 at 7.) As to Dr. Klopp’s qualifications, Plaintiff asserts that Dr. Klopp lacks
“experience, education, and/or expertise on mechanical oil seal design and dynamics.” (Id. at
14.) Therefore, Plaintiff asserts that Dr. Klopp is unqualified to opine in this case because this
case concerns mechanical oil seals. (Id.) Next, Plaintiff argues that Dr. Klopp’s testimony and
report lack “any reliable methodology.” (Id. at 16.) Specifically, Plaintiff asserts that Dr. Klopp
did not perform a root cause analysis, perform a substantive calculation, take measurements of
the seals, interview any witnesses aside from Defendant’s own representatives, inspect the Seals
or Compressors, or visit the Sarnia facility. (Id.) Instead, Plaintiff asserts that Dr. Klopp “simply
regurgitat[ed] and parrot[ed] [] the hearsay reports of other third parties that were involved in the
[o]il [s]eal failures.” (Id.) Regarding the “fit” of Dr. Klopp’s testimony and report, Plaintiff
argues that Dr. Klopp would not assist a trier of fact because he ignored critical facts and data
when opining on the seal failures and compressor shutdowns and failed to lay eyes on the
Siemens root cause analysis of the C3 Compressor. (Id. at 17–18.) Thus, Plaintiff asserts that
Dr. Klopp’s testimony and report are unmoored from the evidence of record, lack a factual

foundation, and should be excluded. (Id. at 18.) Finally, Plaintiff asserts that, should Dr. Klopp’s
testimony not be excluded, his testimony should be limited to rebutting Dr. Green’s opinions
because he presented “new and untimely affirmative expert opinions and theories relating to
causation that should have been issued in an affirmative expert report on or before October 27,
2023.” (Id. at 19.)
In contrast, Defendant argues that Dr. Klopp is qualified to rebut Dr. Green’s opinions
because Dr. Klopp is a mechanical engineer with more than forty (40) years of experience, which
includes conducting root cause analysis failures. (Doc. No. 49 at 15.) Defendant asserts that Dr.
Klopp opines on Dr. Green’s root cause analysis of the compressor failures, and therefore his
education and experience in conducting root cause failure analyses of turbomachinery are

directly relevant here. (Id.) As to Dr. Klopp’s methodology, Defendant argues that Dr. Klopp is
a rebuttal expert whose purpose is to analyze “the facts[,] opin[e] on [,] and rebut[] Dr. Green’s
opinions on the root cause of the compressor failures”—which Dr. Klopp did. (Id. at 19.)
Further, Defendant asserts that Dr. Klopp need not have conducted his own root cause analysis
because he is a rebuttal expert. (Id. at 20.) Therefore, Dr. Klopp’s methodology of “applying his
expertise, and reviewing the record, to critique Dr. Green’s opinions” is reliable. (Id. at 21.)
Defendant asserts that Dr. Klopp’s testimony “fits” the case because Dr. Klopp “opines on the
root cause analysis of the compressor failures” which is “at the heart of the case[] and is one of
the key disputed factual issues.” (Id. at 22.) Finally, Defendant argues that Dr. Klopp’s opinions
are within the bounds of a rebuttal expert because Dr. Klopp’s opinion that “the Seals did not
cause the Compressors to shut down” and “something about the major overhaul triggered the
subsequent seal failures” are not new and affirmative theories of defect but refutations of Dr.
Green’s opinion. (Id. at 23–24.) The Court first addresses Plaintiff’s challenge to Dr. Klopp’s

qualifications to serve as an expert in this case before addressing Plaintiff’s arguments as to
reliability and fit.
2. Qualifications

Plaintiff contends that Dr. Klopp has no education, experience, or knowledge in
mechanical oil seals and therefore should not be qualified because Dr. Klopp cannot opine
meaningfully on the Seals which are the issue at the heart of this case. (Doc. No. 53 at 3.) On
the other hand, Defendant argues that Dr. Klopp has experience and expertise in mechanical
engineering and root cause analyses which makes him more than qualified to opine and rebut the
root cause failure analysis and opinions of Dr. Green. (Doc. No. 49 at 13–16.)
Dr. Klopp received his Bachelor of Science degree in mechanical engineering, two
Masters of Science degrees in mechanical engineering and applied mathematics, and a Doctor of
Philosophy degree in Mechanical Engineering. (Doc. No. 41 at 11.) Dr. Klopp holds
professional engineer licenses in California, Texas, Washington, Michigan, and Nevada, and he is
a fellow of the American Society of Mechanical Engineers. (Id.) Dr. Klopp has been practicing
in the field of mechanical engineering for over forty (40) years, including with his present
employer Exponent. (Id.) At Exponent, Dr. Klopp is a Principal Engineer, a position in which
he has investigated “failures of all kinds.” Of note, Dr. Klopp possesses experience in failure
analysis and in the engineering and application of turbomachinery and their parts, which is
derived from work experience conducting failure analyses on compressors, steam and gas
turbines, generators, and other machinery of that sort. (Id. 11–12.) Dr. Klopp has also published
extensively within the last ten years on topics related to mechanical engineering including co-
authoring six (6) reports, eighteen (18) academic papers, six (6) book chapters, and other
presentations and lectures. (Id. at 61–70.)

Upon consideration of the above, the Court concludes preliminarily that Dr. Klopp
appears qualified to offer rebuttal testimony regarding the cause of the seal failures based on his
expertise in mechanical engineering and failure analyses. Although Plaintiff asserts that Dr.
Klopp’s experience and expertise have nothing to do with mechanical oil seals, the Court finds
that Dr. Klopp’s knowledge, experience, and expertise in the realm of mechanical engineering
and root cause failure is appropriate for the trier of fact’s determination of the issue of the cause
of the compressor failures. Therefore, the Court finds that Dr. Klopp meets the qualification
requirement of Rule 702 and turns to the reliability of Dr. Klopp’s opinions.
3. Reliability

As set forth more fully above, the reliability inquiry focuses on an expert’s methodology
and whether he or she has good grounds for the opinion offered. See In re Paoli, 35 F.3d at 746.
In re Paoli sets forth numerous factors to guide the Court in evaluating the reliability of a
witness’s methodology as follows:
(1) whether a method consists of a testable hypothesis; (2) whether the method has
been subject to peer review; (3) the known or potential rate of error; (4) the
existence and maintenance of standards controlling the technique’s operation; (5)
whether the method is generally accepted; (6) the relationship of the technique to
methods which have been established to be reliable; (7) the qualifications of the
expert witness testifying based on the methodology; and (8) the non-judicial uses
to which the method has been put.
See id. at 742 n.8. However, those factors “are neither exhaustive nor applicable in every case.”
See Pineda, 520 F.3d at 248 (citing Kannankeril, 128 F.3d at 806–07 and Kumho Tire, 526 U.S.
at 151).
In his report, Dr. Klopp states that the scope of his work was to “assess whether Dr.

Green had followed proper engineering and scientific methods in developing his conclusions,
whether [Dr. Green’s] conclusions are supported by the available evidence, and [whether Dr.
Green’s conclusions] were correct.” (Doc. No. 41 at 13.) In accordance with those objectives,
Dr. Klopp analyzed Dr. Green’s report and related evidence, deposition testimony, and the
reports of third parties. See, e.g., (id. at 24 n.14, 25 n.22, 27 n.29, 29–34, 40 n.58, 41 n.73).
Ultimately, based on his analysis of those materials, Dr. Klopp determines that Dr. Green’s report
is erroneous because: (1) Dr. Green fails to conduct a comprehensive root cause analysis; (2) Dr.
Green fails to adequately apply the scientific method to his investigation of the cause of the
compressor failures; (3) Dr. Green fails to reference specific publications that provide “evidence
of relevant experience when making his arguments related to the alleged seal failures;” and (4)

Dr. Green fails to base his opinions on sufficient facts. (Id. at 49–59.)
In its brief in support of its motion, Plaintiff argues that Dr. Klopp’s opinion is not
reliable because “his entire report is simply a regurgitation and parroting of the hearsay reports of
other third parties that were involved in the Oil Seal failures—without any attempt to verify the
accuracy or reliability of those hearsay reports.” (Doc. No. 48 at 16.) Defendant counters that
Dr. Klopp is a rebuttal expert and as such his methodology of reviewing the deposition
testimony, the exhibits thereto, the third party reports on the compressor failures, and Dr. Green’s
Report is more than reliable because “‘a rebuttal expert has ‘no burden to produce models or
methods of their own.’” (Id. at 19 (quoting Rinaldi v. SCA La Goutte, D’Or, No. 16-cv-01901,
2021 WL 4553850, at *15–16 (S.D.N.Y. Sept. 30, 2021)).)
The Court agrees with Defendant that Dr. Klopp’s methodology is reliable. The Court
notes that the case law Plaintiff relies upon is inapposite because the cases either deal with expert

reports and opinions that are not rebuttal reports and opinions or else address a rebuttal report
relying on a settlement agreement to calculate to royalty damages. See, e.g., Bruno v. Bozzuto’s,
Inc., 311 F.R.D. 124, 127–128 (M.D. Pa. 2015) (recording the opinion of the plaintiffs’ two
expert witnesses as providing a determination on damages and not as a rebuttal of another
expert’s report); In re TMI Litigation, 193 F.3d 613, 716 (3d Cir. 1999) (reporting expert Douglas
Crawford-Brown’s report as offering an affirmative opinion on the radiation dose that Three Mile
Island residents were exposed to rather than a rebuttal of another expert’s report); Fundamental
Innovation Sys. Int’l LLC v. Anker Innovations Ltd., No. 21-cv-0039, 2024 WL 2258127, at *4
(D. Del. May 17, 2024) (stating that a litigation settlement agreement used to calculate royalties
as a rebuttal to another expert’s opinion is not reliable methodology). Those cases and their

circumstances are inapposite to the Court’s determination here because Dr. Klopp’s explicit
purpose is to refute and rebut the opinions of Plaintiff’s expert Dr. Green—which he has done—
and Dr. Klopp’s opinions concern the root cause analysis and scientific method applied by Dr.
Green to the compressor shutdowns. See (Doc. No. 41 at 13; 49 at 19); Pritchard v. Dow Agro
Sciences, 263 F.R.D. 277, 284–85 (W.D. Pa. 2009) (finding that a rebuttal report is permissible
“if it contains merely an elaboration of and [is] consistent with an opinion/issue previously
addressed in the expert report”). Therefore, although Plaintiff contends that Dr. Klopp’s Report
is based on third-party reports of others with no independent verification, the Court finds that Dr.
Klopp’s use of the third-party reports, his knowledge and expertise, Dr. Green’s Report, and
evidence in the record constitutes a reliable methodology to rebut and refute Dr. Green’s Report
and opinions. Next, the Court turns to whether Dr. Klopp’s opinions “fit” this case.
4. Fit

The fit requirement is ultimately a question of whether the expert’s opinions are
“connected to the question at issue.” See In re Paoli, 35 F.3d at 745 n.13. Although the standard
is “not that high,” the standard is nonetheless “higher than bare relevance.” See id. at 745.
Plaintiff argues that Dr. Klopp’s report and opinions should be excluded because Dr.
Klopp “ignores critical facts and data when opining on the cause of the Oil Seal Failures [sic]
and Compressor [sic] shutdowns … [and therefore] Dr. Klopp’s [opinions] are not based in the
evidence of record and lack factual foundation.” (Doc. No. 48 at 17–18.) In contrast, Defendant
asserts that Dr. Klopp’s opinions “fit” this case because “Dr. Klopp opines on the root cause
failure analysis of the compressor failures.” (Doc. No. 49 at 22.)
The Court agrees with Defendant that Dr. Klopp’s opinions “fit” this case. At its core,
this case concerns the multiple seal failures and shutdowns of Plaintiff’s Compressors and the

impact that they had on Plaintiff’s business. See (Doc. No. 1 ¶ 24). Plaintiff asserts, through its
complaint and expert witness Dr. Green, that the cause of the compressor shutdowns are the
Seals that Defendant defectively designed. (Id.; Doc. No. 52-1 ¶ 134(a).) Dr. Klopp’s opinion is
that Dr. Green misapplied the scientific method, and his conclusions are contradicted by the
reports of others, thus Dr. Green’s conclusion that the Compressors shut down due to defective
Seals is untrustworthy. (Doc. No. 41 at 49.) Put differently, Dr. Klopp’s opinions are “connected
to the question at issue,” see In re Paoli, 35 F.3d at 745 n.13, because his opinions use the
evidence in the record to contradict Plaintiff’s and Dr. Green’s conclusion that the Seals are
defective and caused the Compressors to shut down. Accordingly, the Court finds that Dr.
Klopp’s testimony and report “fit” the case. Lastly the Court addresses Plaintiff’s argument that
Dr. Klopp’s testimony exceeds the scope of rebuttal testimony.
5. Scope of Dr. Klopp’s Rebuttal Testimony
A rebuttal or reply expert report’s purpose is “solely to contradict or rebut evidence on

the same subject matter identified by another party.” See Fed. R. Civ. P. 26(a)(2)(D)(ii); see also
Avco Corporation v. Turn and Bank Holdings, Inc., No. 12-cv-01313, 2017 WL 2224915, at *19
(M.D. Pa. May 22, 2017) (“[A] party may only submit an expert rebuttal ‘if the evidence is
intended solely to contradict or rebut evidence on the same subject matter identified by another
party’ according to deadlines created by the court.”); Withrow v. Spears, 967 F. Supp. 2d 982,
1001 (D. Del. 2013) (“A rebuttal expert or reply report is proper if the intent of the report is
“‘solely to contradict or rebut evidence on the same subject matter’ identified by the opposing
party’s expert report.”). “Such rebuttal and reply expert reports ‘may cite new evidence and data
so long as the new evidence and data is offered to directly contradict or rebut the opposing
party’s expert.’” Withrow, 967 F. Supp. at 1002 (quoting Glass Dimensions, Inc. ex rel. Glass

Dimensions, Inc. Profit Sharing Plan & Trust v. State St. Bank & Trust Co., 290 F.R.D. 11, 16
(D. Mass. 2013)). However, rebuttal and reply expert reports will be considered improper if they
“simply address the same general subject matter as a previously-submitted report, but do not
directly contradict or rebut the actual contents of that prior report.” See id.
Plaintiff argues that Dr. Klopp is a rebuttal expert, but “Dr. Klopp affirmatively opines
that the [Seals] did not cause the [c]ompressor shutdowns … that ‘something about the major
overhaul triggered the subsequent seal failures[,]’ and that ‘ARLANXEO did not properly
operate, maintain, or repair the subject compressors.’” (Doc. No. 48 at 18–19.) Plaintiff
characterizes those opinions as impermissible testimony for a rebuttal expert witness because
those opinions are “new and untimely affirmative expert opinions and theories relating to
causation that should have been issued in an affirmative expert report on or before October 27,
2023.” (Id.) In Plaintiff’s reply brief, Plaintiff identifies eleven affirmative conclusions
proffered by Dr. Klopp: (1) “[s]omething about the major overhaul triggered the subsequent seal

failures;” (2) “[t]he hydrodynamic lubrication in the compressor routinely broke down …
facilitating the seal failures;” (3) “[t]he seals failed as a result of [Arlanxeo’s] operation and
maintenance and not due to a seal design defect;” (4) “[s]omething about the compressor had
changed to trigger … the seal failures which [ensued];” (5) “[t]o a reasonable degree of
engineering certainty, something about the major overhaul triggered the subsequent seal
failures;” (6) “[t]he hydrodynamic lubrication in the compressor likely caused the seals to fail;”
(7) “[t]he evidence points to high forces from shaft radial excursions as being the main cause of
the bushing failures;” (8) “[t]he evidence shows that the Kaydon seal failures are a symptom of
[Arlanxeo’s] actions and inactions;” (9) “[c]learly, something about the [C]ompressors changed
at that time which caused the seals to begin failing;” (10) “[Arlanxeo’s] operation, maintenance,

and repairs caused the seal failures;” and (11) “[t]he repeated seal failures were a symptom of old
age.” (Doc. No. 53 at 10–11.) Defendant does not dispute Dr. Klopp’s status as a rebuttal
expert. (Doc. No. 49 at 5, 7, 23–25.) Defendant responds to Plaintiff’s argument by stating that
Dr. Klopp’s opinions are within the proper scope of rebuttal because they “are proffered in direct
rebuttal to Dr. Green’s opinions on the root cause of the failures.” (Id. at 24.)
The Court finds that Dr. Klopp’s Report and conclusions properly contradict and rebut
Dr. Green’s conclusions. The eleven (11) conclusions of Dr. Klopp that Plaintiff lists as
improper affirmative conclusions are each responsive and contradictory to Dr. Green’s
conclusions. For example, conclusions one through seven (1–7), ten (10), and eleven (11)
directly contradict Dr. Green’s conclusions that the design of the bushing seal has inherent
weaknesses that caused the failure. Compare (Doc. No. 52-1 ¶ 134(b)) with (Doc. No. 53 at 10–
11 (listing conclusions one through eleven (1–11))). Dr. Klopp’s conclusions one (1), three (3),
eight (8), and nine (9) contradict Dr. Green’s closing observation that the Compressors “operated

under certain operating conditions, while complying with all of requirements [sic] of the
compressors manufacturers limits.” Compare (Doc. No. 52-1 ¶ 134(f)) with (Doc. No. 53 at 10–
11 (listing conclusions one through eleven (1–11))). And, lastly, all eleven (11) conclusions
rebut and refute Dr. Green’s ultimate conclusion that the design of the Seals caused the failures
that in turn caused the Compressor shutdowns, which adversely impacted Plaintiff’s rubber
production. Compare (Doc. No. 52-1 ¶ 134(f) (stating Dr. Green’s ultimate conclusion that
“[Defendant’s] [S]eals as refurbished by [Defendant] were at fault for the entire Compressor trip
and shut down, and with it, adversely impacting the plant’s rubber production”) with (Doc. No.
53 at 10–11 (providing, in essence, that poor maintenance and the Compressors themselves, not
the seal design, were the impetus for the seal failures and compressor shutdowns). The Court

disagrees with Plaintiff’s assertion that the conclusions in Dr. Klopp’s Report are improper
affirmative opinions because all eleven conclusions that Plaintiff asserts as evidence of an
affirmative opinion contradict and rebut Dr. Green’s assertions that the design of the Seals caused
their failures, that the bushing seals have inherent weaknesses, and that the Compressors shut
down due to seal failures.
The Court will grant Plaintiff’s request to limit Dr. Klopp’s testimony to rebuttal
testimony because both parties agree that Dr. Klopp’s purpose is to rebut and refute the testimony
of Dr. Green; however, the Court concludes that the opinions of Dr. Klopp presented in his report
do not exceed the scope of rebuttal expert testimony. See (Doc. Nos. 48 at 18–19; 49 at 5, 7, 23–
25). Accordingly, the Court will deny Plaintiff’s Motion to Exclude the Testimony and Report of
Dr. Klopp. The Court turns to Defendant’s Motion to Exclude the Report, Testimony, and
Opinions of Mr. Hall.
C. Defendant’s Motion to Preclude the Expert Reports, Testimony, and
Opinions of Mr. Hall

Defendant seeks the exclusion of Mr. Hall’s reports, testimony, and opinions on the
grounds that he provides an opinion on the law and legal standards that is unhelpful to the trier of
fact, and improvidently “substitutes an expert’s judgment for the jury’s [judgment].” (Doc. No.
45 at 5.) However, Plaintiff clarifies that it does not seek to offer Mr. Hall’s reports to the jury,
but rather submits his reports to the Court under Federal Rule of Civil Procedure 44.1. (Doc. No.
51 at 6.) Accordingly, the Court reviews Mr. Hall’s report under the standards of Rule 44.1
rather than Federal Rule of Evidence 702.
1. Legal Standards under Rule 44.1

Federal Rule of Civil Procedure 44.1 governs the Court’s determination of foreign law
and states:
A party who intends to raise an issue about a foreign country's law must give notice
by a pleading or other writing. In determining foreign law, the court may consider
any relevant material or source, including testimony, whether or not submitted by
a party or admissible under the Federal Rules of Evidence. The court's
determination must be treated as a ruling on a question of law.

See Fed. R. Civ. P. 44.1. In accordance with Rule 44.1, courts may rely upon their own research
and/or the submissions by the parties, when considering foreign law. See Nat’l Group for
Commc’ns & Comput., Ltd. v. Lucent Techs. Int’l, Inc., 331 F. Supp. 2d 290, 294 (D.N.J. 2004).
The most common way courts determine foreign law is through expert testimony. See Inter
Medical Supplies, Ltd. v. EBI Medical Systems, Inc., 181 F.3d 446, 459 (3d Cir. 1999). “The use
of an expert report to assist the Court in its determination of foreign law is entirely different from
use of an expert report, pursuant to [Federal Rule of Evidence] 702, [] to aid the jury in
determining the facts.” HFGL Ltd. v. Alex Lyon & son Sales Managers and Auctioneers, Inc.,
264 F.R.D. 146, 149 (D.N.J. 2009) (internal quotations omitted).
2. The Proposed Foreign Law Report of Mr. Hall

Plaintiff argues that this case is governed by Ontario law. (Doc. No. 51 at 5.) Plaintiff
tenders the report of Mr. Hall “to aid the Court in its determinations” on the laws of the province
of Ontario with respect to breach of contract, breach of warranty, and negligence. (Id.) Mr.
Hall’s report concludes the following:
In this case, the elements of breach of contract are established. The Contracts are
valid and subsisting. [Dr.] Green[’s] Report establishes that [Defendant] has failed
to perform its obligations under the [c]ontracts. [Defendant] has failed to design,
refurbish, and repair the [S]eals in a good and workmanlike manner to be free of
defects, contain no contaminants, and be fit and sufficient for the purposes intended.
The expectation damages flowing from that breach are as set out in [Mr. Wolf’s]
Report. Consequently, under Ontario law, [Defendant] is liable to Arlanxeo for
breach of contract in the amount set out in [Mr. Wolf’s] Report.

In this case, the implied conditions as to quality or fitness arise and have been
breached. [Dr.] Green[’s] Report establishes that [Defendant] supplied seals that
were not reasonably fit for their purposes and were not of merchantable quality.
[Defendant] failed to design, refurbish and repair the seals in a good and
workmanlike manner to be free of defects, contain no contaminants, and be fit and
sufficient for the purposes intended. This constitutes a further breach of the
[c]ontracts, leading to the same liability as set out under the heading “Breach of
Contract.” Consequently, under Ontario law, [Defendant] is liable to Arlanxeo for
breach of warranty [].

In this case, the elements of negligence are established. A manufacturer clearly
owes a duty of care to the ultimate user of the manufactured goods, and as a result
[Defendant] owed Arlanxeo a duty of care. [Dr.] Green[’s] Report establishes that
there has been a breach of the standard of care by [Defendant]. [Mr.] Wolf[’s]
Report demonstrates that Arlanxeo has suffered damages. [Dr.] Green[’s] Report
also establishes causation. Consequently, under Ontario law, Kaydon is liable to
Arlanxeo for negligence in the amount set out in [Mr.] Wolf[’s] Report.

In my opinion, under Ontario law, and based on the assumptions set out above,
Arlanxeo has standing to assert the causes of action and recover the damages
alleged in the Complaint and as further described and quantified [].
(Doc. No. 51-1 at 8–10 (cleaned up).) In his reply report, Mr. Hall also concludes the following:
In my opinion, under Ontario law Arlanxeo is able to recover the Arlanxeo
Singapore [d]amages and the Arlanxeo Switzerland [d]amages from [Defendant]
on three independent bases: (1) pursuant to the Assignment agreement; (2) by
application of the transferred loss principle; and (3) by application of the principle
that amounts paid as a settlement as a result of a breach of contract constitute
damages for that breach of contract.

As a result, under Ontario law Mr. Pocalyko’s criticism that Arlanxeo’s damages
expert of analyzed sales volumes and pricing for Arlanxeo Singapore and Arlanxeo
Switzzerland but not Arlanxeo itself is misplaced and irrelevant.

Further, in my opinion, under Ontario law, the Insurance Proceeds must not be
deducted from the damages recoverable by Arlanxeo from Kaydon, on two
independent bases: (1) pursuant to the Insurance Settlement Agreement, the insurer
assigned its subrogation rights to Arlanxeo; and (2) by virtue of the private
insurance exception to the rule against double recovery.

(Doc. No. 42-6 at 10–11.)
3. Mr. Hall’s Report and Opinions on Ontario Contract and Tort Law

In its motion, Defendant argues that Mr. Hall’s opinion and report solely concern Ontario
law and applying Ontario law to the facts of this case. (Doc. No. 45 at 5–7, 15.) Opposingly,
Plaintiff argues that Mr. Hall’s opinion and report are submitted not pursuant to Federal Rule of
Evidence 702 but rather under Federal Rule of Civil Procedure 44.1 (Doc. No. 51 at 10), which
permits courts to consider relevant materials, sources, or testimony when determining foreign
law, see Fed. R. Civ. P. 44.1. Plaintiff also argues that Defendant should be barred from using a
foreign law expert in this case because it “failed to disclose any expert witness on Ontario law in
accordance with the requirements of [Rule] 26.” (Doc. No. 51 at 6.) In Defendant’s reply brief,
Defendant asserts that: (1) Plaintiff misled Defendant by asserting that Mr. Hall’s opinions and
reports were being submitted pursuant to Rule 26; (2) Plaintiff should compensate Defendant for
its costs and fees in taking the deposition of Mr. Hall and in preparing and filing this motion; (3)
the Court should preclude Mr. Hall’s report and opinion because it goes beyond the bounds of
Rule 44.1 by stating legal opinions that apply the foreign law to the facts of the case; and (4)
Defendant should not be precluded from filing affidavits on foreign law because Rule 26
deadlines do not apply to Rule 44.1. (Doc. No. 54 at 9, 13, 15.)

The Court will deny Defendant’s Motion to Preclude the Expert Reports, Testimony, and
Opinions of Mr. Hall but will disregard the portions of the testimony and report that apply the
law of Ontario to the facts of the case. First, both parties agree that Mr. Hall’s report and
opinions are submitted pursuant to Federal Rule of Civil Procedure 44.1 rather than Rule 702.
(Doc. Nos. 51 at 6; 54 at 12–13 (reasoning that Defendant itself wasted time and effort because
Mr. Hall’s report was submitted pursuant to Rule 44.1 and not Rule 26 and Rule 702).)
Therefore, Defendant’s motion to preclude on the basis of Rule 702 is inapplicable. Second, as
to impermissible conclusions and assertions in Mr. Hall’s opinions and reports, the Court agrees
with Defendant that they do not comport with Rule 44.1. (Doc. No. 54 at 13.) Defendant asserts
that Mr. Hall’s opinions and report, in Mr. Hall’s own words, “apply the law to the facts, [to] then

reach[] his opinions.” (Id. at 14.) Defendant offers several examples of conclusions that Mr.
Hall includes in his report including the following: (1) “under Ontario law, [Defendant] is liable
to Arlanxeo for breach of contract in the amount set out in [] [Mr.] Wolf[’s] Report”; (2) under
Ontario law, [Defendant] is liable to Arlanxeo for negligence in the amount set out in [] [Mr.]
Wolf[’s] Report”; (3) “under the law of Ontario, Arlanxeo is entitled to recover the Arlanxeo
Singapore Damages and the Arlanxeo Switzerland Damages;” and (4) “under the law of Ontario,
the Insurance Proceeds [sic] must not be deducted from the damages recoverable by Arlanxeo
from [Defendant].” (Id. at 14–15.)
The Court agrees with Defendant that the conclusions presented in Mr. Hall’s Report go
beyond a recitation of the law of Ontario because they provide opinions that apply the law to the
facts of the case and give an ultimate resolution of the case, which “invade[] the province of the
fact finder and [] [are] not an appropriate function of expert testimony under Rule 44.1.” See ID

Sec. Sys. Canada, Inc. v. Checkpoint Sys., Inc., 198 F. Supp. 2d 598, 623 (E.D. Pa. 2002).
However, the Court will not preclude Mr. Hall’s expert opinions and reports in their entirety
because, as other courts in this Circuit have held, the parts of Mr. Hall’s expert opinions and
reports that do not impermissibly invade the province of the fact finder are relevant and would
assist this Court in determining the substantive law of Ontario, provided that Ontario law applies
in this case. See, e.g., HFGL Ltd., 264 F.R.D. at 149–50 (allowing the admission of portions of
an expert’s report on English law that do not seek to guide the court in determining the facts); ID
Sec. Sys. Canada, Inc., 198 F. Supp. 2d at 623 (allowing the admission of portions of an expert’s
report on Ontario law that do not seek to guide the court in determining the facts). Accordingly,
the Court finds that portions of Mr. Hall’s report and opinions are relevant materials for

determining foreign law and admissible for consideration by the Court under Rule 44.1.
As to Plaintiff’s request to bar Defendant from using a foreign law expert, the Court will
deny that request. Plaintiff’s request to bar Defendant from using a foreign law expert is based
on Defendant’s failure to submit a timely report pursuant to Rule 26. (Doc. No. 51 at 6.)
Defendant argues that Rule 26 does not apply to Rule 44.1 expert reports. (Doc. No. 54 at 15–
16.) The Court concludes that Rule 26 does not apply to Rule 44.1 because the plain language of
Rule 26 states that disclosure concerns “any witness [a party] may use at trial to present evidence
under Federal Rule of Evidence 702, 703, or 705.” See Fed. R. Civ. P. 26(a)(2)(A). Here, Mr.
Hall’s report is submitted neither for trial nor under Rule 702, 703, or 705, but rather to the Court
under Rule 44.1. Therefore, any rebuttal report provided by Defendant would likewise be
submitted to the Court under Rule 44.1, which means that Rule 26 deadlines do not apply. Other
courts agree that submissions provided to a court under Rule 44.1 are not governed by Rule 26
deadlines. See, e.g., Clarke v. Marriott Int’l, Inc., 403 F. Supp. 3d 474, 480 (D.V.I. 2019)

(holding that parties’ submissions of foreign law expert reports pursuant to Rule 44.1 are not
bound by the expert witness disclosure deadlines of Rule 26(a)(2)); De Fernandez v. Seaboard
Marine, Ltd., No. 20-cv-25176, 2022 WL 2869730, *9 (S.D. Fla. July 21, 2022) (agreeing that
foreign law experts under Rule 44.1 are not required to be disclosed in compliance with Rule
26). Accordingly, the Court will deny Plaintiff’s request to bar Defendant from using a foreign
law expert.
As to Defendant’s request that Plaintiff to compensate Defendant, the Court will deny
that request. The Court acknowledges that Defendant incurred costs and fees when deposing Mr.
Hall and preparing this motion to preclude Mr. Hall pursuant to Rule 702. (Doc. No. 54 at 13.)
However, the Court finds that the deposition of Mr. Hall is not grounds for compensation when

that deposition is part of the process applicable to Rule 44.1 experts. See Forrestal Guarani S.A.
v. Daros Int’l, Inc., No. 03-cv-04821, 2012 WL 13187472, *9 (D.N.J. Apr. 2, 2012) (“Th[e]
burden [of demonstrating a foreign law’s content under Rule 44.1] is met by proper, timely
notice of foreign law experts followed by expert reports, responsive expert reports from the other
party, and expert depositions.”). Moreover, the Court finds that the cost and fees associated with
preparing a motion to preclude Mr. Hall’s reports, testimony, and opinions do not constitute
grounds for compensation because the motion ultimately served as the mechanism by which
Defendant could seek to have the Court disregard certain portions of Mr. Hall’s report from
consideration.
Accordingly, the Court will deny Defendant’s Motion to Preclude the Expert Reports,
Testimony, and Opinions of Mr. Hall, but the Court will disregard the portions of Mr. Hall’s
testimony and report that apply the law to the facts of this case, deny Plaintiff’s request to bar
Defendant from using a foreign law expert, and deny Defendant’s request to compel Plaintiff to

compensate Defendant for Defendant’s costs and fees in taking the deposition of Mr. Hall and in
preparing and filing this motion. The Court turns to Defendant’s Motion to Preclude the Expert
Report, Testimony, and Opinions of Mr. Wolf.
D. Defendant’s Motion to Preclude the Expert Report, Testimony, and Opinion
of Mr. Wolf

1. The Proposed Damages Report of Mr. Wolf

To prove damages, Plaintiff offers Mr. Wolf as an expert witness who calculated damages
it incurred. (Doc. No. 50 at 6.) Defendant seeks the exclusion of Mr. Wolf’s report, testimony,
and opinions on the grounds that Mr. Wolf lacks qualifications in accounting, his methodology
unreliably makes assumptions about decreases in sales, and his calculations fail to fit because
they do not include the lost profits of Arlanxeo Canada. The report proffered by Mr. Wolf (“Mr.
Wolf’s Report”) as to the damages calculations concludes as follows:
On account of the impacts caused by [Defendant’s] defective [S]eals, Arlanxeo
suffered lost profits from overall lost sales for the period from 16 October[,] 2019
through May[,] 2021 when reliable continuous butyl production was finally
resumed, and inventory levels were restored. In addition, and as a result of the seal
failures, Arlanxeo also incurred substantial incremental repair expenses during this
period and suffered incremental manufacturing costs.

Based on our analyses in Section 4, 5 and 6 above, Arlanxeo’s damages are
summarized [as] follow[s]: Lost Profits $31,019,044; Operational Costs for
Investigation and Repairs $6,869,291; Demurrage $528,766; Utilities $965,037;
Total $39,382,138.

(Doc. No. 50-1 at 39.) Mr. Wolf also prepared a reply report in response to the rebuttal expert
report of Paul W. Pocalyko which concludes the following:
As noted throughout Section 2 above, I generally disagree with the critiques of
my First Expert Report offered by Mr. Paul W. Pocalyko of HKA in his Rebuttal
Expert Report dated 12 January[,] 2024. Moreover, I note that Mr. Pocalyko did
not present any alternative damage calculations based on his critiques.
Accordingly, I maintain my opinions summarized in Section 3 of my First Expert
Report.
…

In sum, it continues to be my opinion, as a direct result of the impacts caused by
[Defendant’s] defective [S]eals, Arlanxeo suffered lost profits from overall lost
sales for the period from 16 October[,] 2019 through May[,] 2021 when reliable
continuous butyl production was finally resumed, and inventory levels were
restored. In addition, and as a result of the seal failures, Arlanxeo incurred
substantial incremental investigation and repair expenses during this period and
suffered incremental manufacturing costs.

Based on our analyses in Section 4, 5 and 6 above, Arlanxeo’s damages are
summarized [as] follow[s]: Lost Profits $31,019,044; Operational Costs for
Investigation and Repairs $6,869,291; Demurrage $528,766; Utilities $965,037;
Total $39,382,138.

(Doc. No. 50-2 ¶¶ 3.1–3.4.) Mr. Wolf notes in his reply report that his damages calculations
“encompasses all of Arlanxeo’s sales of butyl products shipped from all of Arlanxeo’s
manufacturing facilities worldwide.” (Id. ¶ 2.8.2.)
2. Analysis
In its motion, Defendant argues that Mr. Wolf’s opinions should be excluded because: (1)
Mr. Wolf has “zero accounting experience, education, training, or certifications”; (2) Mr. Wolf’s
report and opinions do not fit the case as they fail to calculate lost profits for Arlanxeo Canada
and instead calculate lost profits for Arlanxeo Switzerland, Arlanxeo Singapore, Arlanxeo Brazil,
and Arlanxeo USA; and (3) Mr. Wolf’s methodology assumes that the decrease in sales in 2020
through 2021 was “attributable to the compressor failures (and not for other business reasons or
meaningfully due to Covid) and fails to review Arlanxeo Canada’s financial statements or tax
returns or audit any sales reports.” (Doc. No. 47 at 13–14, 18, 22, 24.)
In response, Plaintiff asserts that Mr. Wolf’s opinions should not be precluded because:
(1) Mr. Wolf is qualified based on his forty-five (45) year career “where he has provided
quantum and loss profit analyses for companies in the industrial manufacturing space”; (2) Mr.
Wolf’s report and opinions are entitled to assume liability and the governance of Ontario law,

which allows for Arlanxeo “to recover the lost profits of its affiliates”; and (3) Mr. Wolf’s
methodology accounts for Covid in his calculations and considers Arlanxeo Canada’s financial
statements just not for lost sales (“Arlanxeo Canada does not have any lost sales”). (Doc. No. 50
at 13, 19, 21, 23–24.)
Upon review of Mr. Wolf’s Report and the briefs of the parties, the Court will deny
Defendant’s Motion to Exclude the Report, Testimony, and Opinions of Mr. Wolf without
prejudice to its ability to refile the motion after any dispositive motions are resolved because Mr.
Wolf’s opinions rely on the applicability of Ontario law to this dispute, an issue which the Court
has not yet resolved. Plaintiff asserts that the law of the Province of Ontario applies to its claims,
whereas Defendant argues that the law of the state of Pennsylvania or Michigan applies. (Doc.

No. 1 ¶ 21 (asserting that Ontario law applies to Plaintiff’s Purchase Orders); Doc. Nos. 6 ¶ 21
(denying Plaintiff’s assertion that Ontario law applies to Plaintiff’s Purchase Orders); 45 at 5 n.1
(arguing that Pennsylvania law or Michigan law might apply instead of Ontario law).) Although
the conflict of law issue was noticed in Plaintiff’s complaint (Doc. No. 1 ¶ 21), as required under
Rule 44.1, see Fed. R. Civ. P. 44.1, Defendant asserts that it intends to raise the issue “with its
forthcoming motion for summary judgment” (Doc. No. 45 at 5 n.1). Therefore, the Court has not
had the opportunity to determine which jurisdiction’s law applies to this dispute. Accordingly,
the Court will deny Defendant’s Motion to Preclude the Expert Report, Testimony, and Opinions
of Mr. Wolf without prejudice to its ability to refile the motion after the Court’s resolution of any
dispositive motion.
IV. CONCLUSION
For all of the foregoing reasons, the Court will deny Defendant’s Motions to Preclude the

Expert Reports, Testimony, and Opinions of Dr. Green, Mr. Hall, and Mr. Wolf and will deny
Plaintiff’s Motion to Exclude the Testimony and Report of Dr. Klopp. An appropriate Order
follows.

---

Source: Frix Law Library, https://www.frixlaw.com/law-library/cases/10835986. Public record. Not legal advice.